Symptom:
CHARGING VOLTAGE HIGH MESSAGE
When Monitored and Set Condition:
CHARGING VOLTAGE HIGH MESSAGE
When Monitored:
During cranking or with the engine running.
Set Condition:
When the Memory Seat Mirror Module receives three high charging
system voltage messages above 15.94 volts over the PCI Bus. Code will remain for 50
ignition cycles.
POSSIBLE CAUSES
PCM TROUBLE CODES
STORED CODE COMMUNICATION PROBLEMS
MEMORY SEAT MIRROR MODULE
INTERMITTENT PROBLEM
TEST
ACTION
APPLICABILITY
1
Turn ignition on.
With the DRBIII
t
read Engine DTCs.
Is the DTC P1594 Charging System Voltage Too High set in the Power Control
Module?
All
Yes
→
Refer to symptom *P1594-CHARGING SYSTEM VOLTAGE TOO
HIGH in the CHARGING category
Perform MEMORY SYSTEM VERIFICATION TEST - VER 1.
No
→
Go To
2
2
With the DRBIII
t
, erase the DTC from Memory Seat Mirror Module.
Turn the ignition switch to the Off position then start the engine and let run for one
minute.
With the DRB check for the same DTC to reset in the MSMM.
Did the same DTC reset?
All
Yes
→
Go To
3
No
→
Test complete.
Perform MEMORY SYSTEM VERIFICATION TEST - VER 1.
3
Note: Visually inspect the related wiring harness. Look for any chafed,
pierced, pinched, or partially broken wires.
Note: Visually inspect the related wiring harness connectors. Look for
broken, bent, pushed out, or corroded terminals.
Note: Refer to any technical service bulletins that may apply.
Were any problems found?
All
No
→
Replace the Memory Seat Mirror Module.
Perform MEMORY SYSTEM VERIFICATION TEST - VER 1.
Yes
→
Repair as necessary.
Perform MEMORY SYSTEM VERIFICATION TEST - VER 1.
670
MEMORY SEAT
Summary of Contents for Caravan 2003
