TEST
ACTION
APPLICABILITY
6
WARNING: DO NOT OPERATE THE DCHA IN AN ENCLOSED AREA SUCH
AS A GARAGE THAT DOES NOT HAVE EXHAUST VENTILATION FACILI-
TIES. ALWAYS VENT THE DCHA’s EXHAUST WHEN OPERATING THE
DCHA. FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN
PERSONAL INJURY OR DEATH.
NOTE: The DCHA Control will store up to three DTCs in its memory.
NOTE: If the DCHA Control detects a new fault in the DCHA system, one
that is not already stored in its memory, the DCHA Control will clear the
oldest of the three stored DTCs, and it will store the new fault’s DTC.
NOTE: If the DCHA control detects a reoccurrence of a stored fault, the
DCHA control will overwrite that fault’s DTC with the most recent occur-
rence.
Turn the ignition on.
On MTC, set the Blend control to the max cool position.
On ATC, set the Driver temperature control to LO (max cool).
Turn the ATC’s or MTC’s Power switch off.
With the DRBIII
t
, erase Cabin Heater DTCs.
Start the engine.
Allow the engine to idle.
Turn the ATC’s or MTC’s Power switch on.
Turn the Blower control to the high speed position.
CAUTION: Do not activate the DCHA Field Mode Test with the engine off.
Failure to follow these instructions may result in internal damage to the
DCHA Heater Module.
NOTE: Do not disconnect the vehicle’s battery or the DCHA’s main power
supply while the DCHA is in operation or in run-down mode. Failure to
follow these instructions may result in excess emissions from the DCHA
during heater operation.
With the DRBIII
t
in Cabin Heater, Systems Tests, select Field Mode and press Enter.
The test will run for approx 8.5 minutes.
On MTC, set the Blend control to the max heat position. Upon completion of the Field
Mode Test, proceed as follows:
On ATC, set the Driver temperature control to HI (max heat). Upon completion of the
Field Mode Test, proceed as follows:
With the DRBIII
t
, read Cabin Heater and Active FCM DTCs.
Turn the Blower control off and turn the ATC’s or MTC’s Power switch off.
Turn the engine off.
Are any DTCs present?
All
Yes, B1811 & B1813 reset
Replace the DCHA Heater Module in accordance with the Service
Information.
Perform CABIN HEATER VERIFICATION TEST - VER 1.
Yes, B1811 Cleared, Other DTC(s) Present
Return to the symptom list and choose the DTC(s).
Perform CABIN HEATER VERIFICATION TEST - VER 1.
No
→
Test Complete.
299
CABIN HEATER
B1811 HEATER OVERHEATED —
Continued
Summary of Contents for Caravan 2003
