TEST
ACTION
APPLICABILITY
3
With the DRBIII
t
in Inputs/Outputs, read the RATCHET state.
Open the sliding door to full open position.
Using a screwdriver, click the latch to the second detent while observing the
DRB111
t
.
Unlatch the latch by pulling the handle switch and observe the DRB111
t
for a state
change.
Repeat this step several times while moving the door in different positions and
wiggling the wiring harness to check for an intermittent short.
Did the DRB111
t
show the switch state changes correctly every time?
All
Yes
→
Replace the Power Sliding Door Module.
Perform BODY VERIFICATION TEST - VER 1.
No
→
Go To
4
4
Disconnect the Sliding Door Control Module C2 connector.
Disconnect the Sliding Door Latch Sensing Switch connector (latch assembly).
Measure the resistance of the Ground wires (both) between the PSD C2 connector
(cavity 20) and the Sliding Door Latch Sensing Switch connector.
Wiggle the harness while observing the ohmmeter.
Is the resistance below 5.0 ohms on both ground wires?
All
Yes
→
Go To
5
No
→
Repair the Ground wire for an open.
Perform BODY VERIFICATION TEST - VER 1.
5
Disconnect the Sliding Door Control Module C2 connector.
Disconnect the Sliding Door Latch Sensing Switch connector (latch assembly).
Measure the resistance of the Sliding Door Ajar Switch Sense wire between the PSD
C2 connector and the Sliding Door Latch Sensing Switch connector.
Wiggle the harness and move the door in different positions while observing the
ohmmeter.
Is the resistance below 5.0 ohms?
All
Yes
→
Go To
6
No
→
Repair the Sliding Door Ajar Switch Sense wire for an open.
Perform BODY VERIFICATION TEST - VER 1.
6
If there are no possible causes remaining, view repair.
All
Repair
Replace the Ratchet Switch (latch assembly).
Perform BODY VERIFICATION TEST - VER 1.
872
POWER DOORS - SLIDING
INCOMPLETE LATCH RELEASE - RATCHET SWITCH FAILURE —
Continued
Summary of Contents for Caravan 2003
