Central Boiler e-Classic 1450 IR, Owner'S Manual

Page: 5 / 72

3
Labeling and Terminology
The outdoor furnace and this owner's manual use the
following terms and symbols to bring attention to the
presence of hazards of various risk levels and important
information concerning the use and maintenance of the
outdoor furnace.
DANGER:
Indicates an imminently hazardous situation
which, if not avoided, will result in death or serious
injury.
WARNING:
Indicates presence of a hazard which
can cause severe personal injury, death, or substantial
property damage if ignored.
CAUTION:
Indicates presence of a hazard which can
cause minor personal injury or property damage if
ignored.
NOTE:
Indicates supplementary information worthy of
particular attention relating to installation, operation, or
maintenance of the outdoor furnace but is not related to
a hazardous condition.
Be sure to follow all instructions and related precautions
as they are meant for your safety and protection. Store
this manual in a readily accessible location for future
reference.
Foreword
This manual is to be used as a guideline for installation,
operation, and maintenance of the E-Classic Outdoor
Wood Furnace.
This manual is organized into six sections for easy
reference.
• Section 1 – Outdoor Furnace Installation;
• Section 2 – Operating Instructions;
• Section 3 – Maintenance;
• Section 4 – Owner Serviceable Items;
• Section 5 – Troubleshooting;
• Section 6 – General Information.
Anyone owning or operating this outdoor furnace must
read, fully understand, and follow all of the information
in this manual.
NOTE: In higher populated areas, extend
the chimney to a height above the roofs of
surrounding buildings (see E-Classic Outdoor
Furnace Installation Scenario illustration in
Planning the Location section).
NOTE: The outdoor furnace may be connected
to an existing boiler system or hot water heating
system by a qualified installer only. However, the
outdoor furnace must not be pressurized.
Tools
Included with each new furnace are tools that are
invaluable for maintenance and cleaning. Use the hoe
to clean the firebox and Reaction Chamber. The Wonder
Bar
®
is used for scraping the firebox and the door frame.
The cleaning rod can be used to break up heavy or
solidified ash in the firebox. The heat exchanger scraper
is used to remove fly ash and deposits from the heat
exchangers.
Measurements
E-Classic 1450 Measurements
A
42 34 5 150 71 59 47 57 73
107 86 13 381 180 150 119 145 185
B C D E F G I H
cm
in.
- Measurement (G) includes two 4 ft (1.2 m) chimney sections.
- Measurement (F) is from firebox door to chimney
inspection cover.
© 2011 Central Boiler
C
A
I
B
D
H
G
E
F
INTRODUCTION
Wonder Bar
Hoe
Cleaning Rod
Heat Exchanger Scraper