Boston Whaler 420 OUTRAGE, Owner'S Manual

Page: 124 / 268

3-30 420 Outrage
Chapter 3 • Systems Overview & Operation
R
Generator Fuel Filter
A fuel filter located on the
starboard wall of the bilge,
forward of the diesel fuel tank
provides clean fuel to the
generator.
A major cause of poor starting
or power loss is the result of a
clogged filter element or a fuel
system air leak.
Fuel Filter Maintenance
Replacing the Filter
Replace the filter according to manufacturers
recommendations or if a power loss is detected.
1. Ensure engine is not running
2. Remove bottom casing.
3. Remove the filter by slowly pulling upward
with a twisting motion.
4. Insert the new filter with a slow
downward twisting motion.
5. Fill the filter with clean fuel.
6. Replace the bottom casing. DO NOT
overtighten.
NOTICE
It is recommended that spare filters are
carried aboard as contaminated fuel can
easily clog a filter.
Maintenance
ACCIDENTAL STARTING can cause severe injury
or death. Disconnect the battery cables before
working on the generator set. Disconnect the
negative, (-) cable first when removing and reconnect
it last when replacing.
!
WARNING
NOTICE
Your first maintenance is required at 35
hours, by a qualified technician, at which time
a maintenance checklist must be completed.
Failure to comply will invalidate the generator
warranty.
Your Fischer Panda operation manual will have a
complete maintenance schedule that will need to be
followed to keep your generator in peak operating
condition.
On/Off Start
Stop
Alarm
Mute
Next
Screen
Set
• Press the On/Off button to
de-activate the panel.
• Close the seacock.
Inspect the parts often and perform required
service at the prescribed intervals (see notice
below). Maintenance work must be performed
by appropriately skilled and suitably trained
maintenance personnel familiar with generator set
operation and service.
• Make sure that ALL
breakers on the AC
Panel are switched
OFF.
OFF OFF OFF OFF
OFF OFF
OFF OFF
OFF
MAIN GENERATOR
PREP
STA
VACUUM ACC
OFF OFF OFF
FWD
CHARG
AFT
CHARG
CABIN
REFRIG
SHORE POWER 1 SHORE POWER 2
MAIN
GEN BRIDGE
120 V AC
WARNING!
GASOLINE VAPORS
CAN EXPLODE
BEFORE STARTING
GENERATOR:
CHECK FOR GASOLINE
VAPORS
OPERATE BLOWER
FOR 4 MINUTES
START
STOP
MODE
KOHLER
BLOWER
OFF
CABIN
OUTLETS
OFF OFF OFF
WATER
HEATER
A/C
PUMP
CABIN
A/C
OFF
AC
ON
OFF OFF OFF
DECK
A/C
FRZ
PLATE
FRZ
ON