Boston Whaler 420 OUTRAGE, Owner'S Manual

Page: 114 / 268

3-20 420 Outrage
Chapter 3 • Systems Overview & Operation
R
Your boat is equipped with a
waste disposal system located
in the head on the starboard aft
side of the cabin. The system
is protected by the “HEAD”
breaker on the DC Breaker
Panel on the port side of the
cabin. The vacuum pump switch must be ON for the
system to function.
The waste system includes an electric VacuFlush
toilet, vacuum generator, a holding tank and thru-
hull vent.
waterways, Freshwater lakes and Impoundments
accessible through locks and other flowing waters
that are navigable interstate by vessels subject to
this regulation. (40CFR 140.3)
NEUTRAL
TROL
L
SYNC
TRANSFE
R
1 LEVEL
THROTTLE
ONL
Y
DOCK
TRIM
UP
DN
NEUTRA
L
TROLL
SYNC
TRANSFE
R
1 LEVER
THROTTLE
ONL
Y
DOCK
12V DC
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
UNSWITCHED
MAIN
24HR
PORT AFT
WINDLASS
AMP 1
WINDLASS
CONTROL
SHOWER
SUMP
ACC
HELM
SEAT
BOW
TABLE
DECK 12V
OUTLETS
HEAD
CABIN
REFRIG
CABIN 12V
OUTLETS
DATA
NETWORK
DATA
NETWORK
BATT SW
CONTROL
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
MAIN
STBD AFT
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
BILGE
PUMPS
LIGHTING
CONSOLE
ELECTRONICS
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
WIPER/
WASHER
TRIM TABS
PREP
STATION
O
OFF
ON
1
O
OFF
ON
1
O
OFF
ON
1
HARDTOP
STEREO
SAT TV
AMP 2
AMP 3
AMP 4
24HR
24HR
When depressed, the “FLUSH” button on the
function panel opens a mechanical seal which allows
a vacuum to force waste through the opening in the
bowl to the vacuum generator and then to the holding
tank.
Operation
• If there is no water in the bowl, depress the
“ADD WATER” button on the function panel
(Fig. 3.21.2).
Electric VacuFlush Head
This boat is equipped with a direct overboard
discharge valve. Discharging of sewage
directly overboard is for use where approved
only. Damage to the system could occur if
the discharge seacock is not open during
operation.
NOTICE
Head System
Environmental Considerations
The Environmental Protection Agency (EPA)
standards state that in freshwater lakes, reservoirs,
impoundments whose inlets or outlets are such as
to prevent the ingress or egress by vessel traffic
subject to this regulation, or in rivers not capable
of navigation by interstate traffic subject to this
regulation, marine sanitation certified by the United
States Coast Guard (U.S.C.G.) installed on vessels
shall be designed and operated to prevent the
overboard discharge of sewage, treated or untreated
or any other waste derived from sewage.
The EPA standards further state that this shall
not be construed to prohibit the carriage of Coast
Guard certified flow through treatment devices
which have been secured so as to prevent such
discharges. They also state that the waters where
a Coast Guard certified marine sanitation device
permitting discharge is allowed include: Coastal
waters, Estuaries, The Great Lakes and Intercoastal
Severe state and federal penalties are levied
for discharging raw sewage and solid waste
in waters where it is not permitted.
Demonstrating that you have disabled the
macerator by locking the system and/or
removing the seacock handle may avoid a fine.
It is illegal for any vessel to dump plastic trash
anywhere in the ocean or navigable waters of
the United States.
NOTICE
Maintenance
Maintenance of the raw water system requires
periodic inspection of the raw water intake strainer
and all fittings and hoses for system integrity to
prevent leaks.
Clean away debris and/or tighten hose connections
as required. The system should be run at least every
other month to keep the pumps impellers in good
condition.
PUMPS” switch on the prep station switch panel.
The spray head is activated by twisting the unit.
NOTICE
The “WATER PUMPS” switch activates both
the freshwater and raw water pumps. If only
one system is required the other pumps can be
turned off via the iPad, Raymarine or Czone on
Vessel View.
ATTENTION
The seacock MUST be in the OPEN position
when washdown is in use. Running the pump
dry may damage the unit.