Boston Whaler 420 OUTRAGE, Owner'S Manual

Page: 123 / 268

3-29 420 Outrage
Chapter 3 • Systems Overview & Operation
420 Outrage
R
• Press the On/Off button on the
remote start panel. The
indicator light will
illuminate and the fuel gauge
will be activated.
• Press and release the START
button. The light will begin
blinking and the generator
will start.
Your owner’s manual packet will have the complete
operations manual for your generator. Be sure to read
the manual before operating the generator. Several
key points are indicated below:
• L o c a t e t h e b l o w e r
switch on the AC Breaker
Panel and operate the
blower for four (4)
minutes. Manually check
the bilge for fuel or fuel
vapor.
• Refer to the Manufacturers Operations Manual
for a Pre-Start Checklist.
• OPEN the generator
seacock.
• Make sure that ALL
breakers on the AC
Panel are switched
OFF.
• Slide the selector on
the AC Panel to
expose the
GENERATOR
& BRIDGE switches.
• Switch the line breakers
ON.
Under no circumstances override the source
select system.
!
WARNING
OFF OFF OFF OFF
OFF OFF
OFF OFF OFF
MAIN GENERATOR
PREP
STA
VACUUM ACC
OFF OFF
OFF
FWD
CHARG
AFT
CHARG
CABIN
REFRIG
SHORE POWER 1
SHORE POWER 2
MAIN GEN BRIDGE
120 V AC
WARNING!
GASOLINE VAPORS
CAN EXPLODE
BEFORE STARTING
GENERATOR:
CHECK FOR GASOLINE
VAPORS
OPERATE BLOWER
FOR 4 MINUTES
START
STOP
MODE
KOHLER
BLOWER
OFF
CABIN
OUTLETS
OFF OFF OFF
WATER
HEATER
A/C
PUMP
CABIN
A/C
OFF
AC
ON
OFF
OFF
OFF
DECK
A/C
FRZ
PLATE
FRZ
ON
OFF OFF ON ON
OFF OFF OFF
MAIN
GENERATOR
PREP
STA
VACUUM ACC
OFF OFF OFF
FWD
CHARG
AFT
CHARG
CABIN
REFRIG
SHORE POWER 1
SHORE POWER 2
MAIN GEN BRIDGE
120 V AC
WARNING!
GASOLINE VAPORS
CAN EXPLODE
BEFORE STARTING
GENERATOR:
CHECK FOR GASOLINE
VAPORS
OPERATE BLOWER
FOR 4 MINUTES
START
STOP
MODE
KOHLER
BLOWER
OFF
CABIN
OUTLETS
OFF OFF
OFF
WATER
HEATER
A/C
PUMP
CABIN
A/C
OFF
AC
ON
OFF OFF
OFF
DECK
A/C
FRZ
PLATE
FRZ
ON
OFF OFF OFF OFF
ON ON
OFF OFF ON ON
OFF OFF OFF
MAIN GENERATOR
PREP
STA
VACUUM ACC
OFF OFF OFF
FWD
CHARG
AFT
CHARG
CABIN
REFRIG
SHORE POWER 1 SHORE POWER 2
MAIN GEN BRIDGE
120 V AC
WARNING!
GASOLINE VAPORS
CAN EXPLODE
BEFORE STARTING
GENERATOR:
CHECK FOR GASOLINE
VAPORS
OPERATE BLOWER
FOR 4 MINUTES
START
STOP
MODE
KOHLER
BLOWER
OFF
CABIN
OUTLETS
OFF OFF OFF
WATER
HEATER
A/C
PUMP
CABIN
A/C
OFF
AC
ON
OFF OFF OFF
DECK
A/C
FRZ
PLATE
FRZ
ON
OFF OFF OFF OFF
ON ON
NOTE: ALWAYS run the blower when operating
below cruising speed.
On/Off Start
Stop
Alarm
Mute
Next
Screen
Set
DO NOT press the button more than once.
Allow for a 60 second cool down period between
cranking attempts.
On/Off Start
Stop
Alarm
Mute
Next
Screen
Set
NOTICE
DO NOT run the generator set out of fuel
because the fuel lines will draw in air and
necessitate bleeding the system before
restarting the unit. The operations manual
included in the owners packet will have
complete instructions on bleeding the fuel
system should it be needed.
OFF OFF OFF OFF
OFF OFF
OFF OFF OFF
MAIN
GENERATOR
PREP
STA
VACUUM ACC
OFF OFF OFF
FWD
CHARG
AFT
CHARG
CABIN
REFRIG
SHORE POWER 1
SHORE POWER 2
MAIN GEN BRIDGE
120 V AC
WARNING!
GASOLINE VAPORS
CAN EXPLODE
BEFORE STARTING
GENERATOR:
CHECK FOR GASOLINE
VAPORS
OPERATE BLOWER
FOR 4 MINUTES
START
STOP
MODE
KOHLER
BLOWER
OFF
CABIN
OUTLETS
OFF OFF
OFF
WATER
HEATER
A/C
PUMP
CABIN
A/C
OFF
AC
ON
OFF OFF
OFF
DECK
A/C
FRZ
PLATE
FRZ
ON
• After a successful
start, breakers can
be switched ON.
Stopping The Generator
If the generator fails to start after the first attempt,
check fuel flow, if ok, attempt start sequence again.
If the unit fails to start after 3 attempts, contact an
authorized dealer/distributor for service.
NOTICE
If the electrical load has been operating at
more than 70% or if the ambient temperature
is higher than 77F, generator temperatures
should be stabilized by turning off breakers at
the AC panel and letting generator run for a
minimum of 5 minutes before shutting down.