43
ABOVE FLOOR SLIDE-OUT
This system operates on an inside ram assembly on a track moved
by a cog gear. Ram is attached to the floor and side wall with a
moving track attached to the slide-out. On larger slides, two (2)
rams will be used with cross shaft connecting the 2 rams. A steel
frame carriage style is used on some models, doing same function
generally as a 12’ slide. Access to these components is inside of
coach, under slide floor.
OPEN :
Hold operation switch until room seals tightly on the
exterior of the unit. DO NOT distort or bend the exterior flanges or
interior fascia by holding the switch in the “ON” position.
CLOSE :
To retract, reverse the procedure and hold button until
the room is fully inside with gaskets sealing to the outer wall. It
takes about 20 seconds to move the slide in or out.
VENTURE RV
does NOT require or suggest blocking, supports,
jacks, etc., to be used under slide outs during extended normal use.
SCHWINTEC WALL SLIDE
System is composed of four tracks placed on the outer sidewall of
slide, two at the bottom and two near roof line. On each side an
extrusion is attached to sidewall with a motor inside at the top of
extrusion, one on each side accessible only from the inside. A gear
mounted to the motor will run on the track to move slide in or out.
Wire harness is along side of extrusion.
It is very important to keep tracks clean from dirt and debris.
Additional information will be found in suppliers manual about
manual operation, error codes and other issues.
Electrical Components
A 12 volt DC motor is located under the frame. It may be inside of
main rail on frame, or on some models it will be on the outer side on
main rail along with front to rear shaft. On the above floor slide, it
will be under the floor of the sofa or dinette. The in wall slide room
system motors are installed in the wall.
Operational switch:
This switch, is a three position, (off - center, in
or out) spring loaded switch. Select which direction you wish to
PDF created with pdfFactory trial version
www.pdffactory.com
