Page 36
5-8
#7040748 - Revision A - September, 2016
Component Removal
MODEL UW-24
MODEL UW-24
Figure 5-16. Lower Compartment Thermistor
Clamp
Thermistor
Grommet
Evap Cover
Control Panel Assembly and Lower Light Bracket
Removal
The control panel assembly and the lower light bracket
are attached to each other and must be removed
together.
To remove the control panel assembly and the lower
light bracket, first remove the wine racks from the unit,
then (See Figure 5-14):
1.
Extract the screws from the service panel, and
remove the service panel.
2.
Disconnect the membrane switch ribbon cable, the
LED ribbon cable, and the lower LED light wires
from the control board
3.
Extract the screws from the control panel assembly
and the lower light bracket from the bottom of the
control panel assembly.
4.
Remove the control panel assembly and lower light
assembly by rotating it down while pulling it toward
the front.
3.
Separate the lower light assembly from the control
panel assembly by sliding them apart (See Figure
5-15).
Lower LED Light Removal
To remove the lower LED light, first remove the control
panel assembly and lower light bracket, then:
1.
Slide LED light out the end of the lower light brack-
et channel (See Figure 5-15).
Compartment Thermistors
The compartment thermistors are attached to the left
side wall within a press-in clamp. The thermistor elec-
trical leads are routed through a wire grommet that is in
a key-hole slot in the left side of the evaporator cover.
To remove one of the compartment thermistor, first
remove the wine racks from the upper or lower section,
then (See Figure 5-16):
1.
Remove the cabinet slides.
2.
Remove the slide spacers and the slide support
spacers.
3.
Remove the evaporator fan cover.
4.
Pull the cabinet thermistor from the clamp.
5.
Pull the evaporator cover forward and feed the cab-
inet thermistor through the grommet.
6.
Cut thermistor’s wire leads six to twelve inches from
back wall, then pull thermistor from compartment.
Figure 5-14. Control Panel Assembly Removal
Control Panel Assembly
Screws (6)
Figure 5-15. Lower LED Light Removal
LED Light
Top Control Panel
Lower Light
Bracket
Front of
Control Panel
Slide
