Sakai SV540 Series, Инструкция по эксплуатации и обслуживанию

Страница: 62 / 108

2. OPERATION
– 56 – – 57 –
WARNING
• Do not remove the radiator cap while the coolant is hot.
• Hot water may be spouted out that can cause scald.
Relieve pressure by slowly turning the cap after the water
temperature is dropped, then remove the cap.
2.11.3 Battery
WARNING
• The battery contains diluted sulfuric acid, which will dissolve clothes and skin.
Should you get battery fluid on your clothes or skin, wash it off immediately with
copious quantities of clean water.
• If you get it in your eyes, rinse them straight away with clean water and
immediately seek the help of a doctor.
• If you accidentally ingest it, drink copious quantities of water and immediately
seek the help of a doctor.
• Always wear safely glasses when handling the battery.
• The battery generates hydrogen gas, so there is a danger of explosions. Avoid
recharging the battery, keep cigarettes and flames away, etc., in poorly ventilated
places when there is a danger of generating sparks.
• The inspection and handling of batteries should be carried out with the engine
turned off and the starter switch in the "OFF" position.
• Be careful not to accidentally connect the two battery terminals with tools or
other metallic objects.
• Tangled terminals may generate sparks due to improper connections, resulting
in the danger of explosions. Make sure terminals are connected firmly.
• The battery is for starting the engine and operating electrical equipment on the
machine. Do not use it for any other purpose.
CAUTION
The power-supply voltage of this machine is 24V.
IMPORTANT
When this machine is shipped, maintenance free battery is installed.
2. OPERATION
– 56 –
2.11.2 Coolant
WARNING
Do not bring an open flame to the antifreeze or do not smoke when handling it. It
is flamable.
CAUTION
Use ethylene glycol-base antifreeze.
For the cooling water, mix the antifreeze in water.
Use softened water as the water to be mixed.
Please refer to the following table for the mixing ratio.
Ambient temperature Always
Amount of anti-freeze 11.5 L (3.0 gal)
Amount of water 11.5 L (3.0 gal)
Ratio 50%
Our machines are filled with a long-life coolant.
The life of the antifreezer is for two years.
Use non-amine type long-life coolant when changing coolant.
CAUTION
Failure to follow this procedure can result in severe engine damage.
Fill : 1) Open heater valves that can be found beneath the engine, and turn the
heater to "heat" mode (only the appropriate machine.)
2) Fill coolant at 3 gallons per minute (12 liters per minute) until coolant
reaches the bottom of the fill neck. Wait for 1 minute, then top up coolant to
the bottom of the fill neck if needed.
3) Start engine and run at "mid" speed for 1 minute or until engine warning
lamp comes on.
4) Turn off engine and top up coolant to bottom of fill neck if needed.
5) Replace coolant cap.