Olympia MILLENNIUM H, Руководство пользователя

Страница: 78 / 113

The Ultimate Ice Resurfacer 66
MILLENNIUM
H
54. Taking hold of the centre of the auger shaft check for movement north, south, east and
west. The bearing should have no play.
55. Inspect the squeegee for proper installation and damage. A damaged squeegee or
improper instalment will effects the wash waters ability to work and the life of the
impeller.
56. Flip the flood towel over and inspect for dirt, debris and wear. The towel is the last
thing to touch the ice, it must be clean and in good report.
57. Inspect both flood water and wash water valve handles for ease of operation and close
both valves.
58. Inspect the hand wheel for free movement, turning the blade both up and down 2 turns
returning it to the original location.
59. Inspect the right hand side auger bearing for proper operation.
60. Take hold of the centre of the auger shaft and move it to check for movement north,
south, east and west. The bearing should have no play.
61. Run your hand on the bottom of the left hand side runner of the conditioner from BACK
TO FRONT, check for burrs on the runner and note the blade position. If there are burrs
present use a flat file to remove them. The blade must be above the runner to prevent
damage to the ice. NEVER RUN YOUR HAND FROM FRONT TO BACK ON THE RUNNER!!!
62. Inspect the conditioner bumper wheel making sure it spins freely.
63. Replace all conditioner cover plates and retaining pins
64. Open the compartment under the seat, flip the switch to hand pump mode and operate
the system. You can lower the conditioner slightly for this procedure. When pumping
the conditioner should fully rise and then the snow bin should start to rise. Flip the
hand pump switch back to drive.
65. Removing the key from your pocket place it in the ignition
66. Using the 3 points of contact, safely mount the OLYMPIA. Never use the arm rest as a
grab handle!
67. Start the OLYMPIA and make sure the OIL PRESSURE gauge is operating and you have oil
pressure. If you do not, shut off the OLYMPIA immediately.