NorAM 65ET T4 FINAL, Руководство оператора

Страница: 91 / 194

NORAM 65ET GRADER
4-13
Lubrication and Maintena
nce - Grader Compon
ents
4
Every 10 Hours or Daily
Diesel Exhaust Fluid (DEF) - Check / Add
Take care when dispensing DEF. DEF that has been spilled will attack paint and metal. Spills should
be cleaned immediately. All surfaces should be wiped clean and rinsed with water.
Shut off engine before filling tank. Fill tank at the end of each day.
NOTICE:
Stopping the engine immediately after the engine has been working under load can result in
overheating of engine components. Refer to
"Machine Shutdown Procedure"
, page
3-6
to allow the
engine to cool and to prevent excessive temperatures in the turbocharger housing and DEF injector.
NOTICE:
Allow at least 2 minutes after engine has stopped before turning master switch OFF.
Disconnecting battery power too soon will prevent purging of the DEF lines after engine is shutdown.
DEF capacity: 5 gal (19 L)
To add DEF to the machine, open access door, left of the
engine access door on the left side of the machine. The
DEF cap is colored blue. Clean area around DEF cap.
Remove cap
(1)
and place in a clean area. After filling
tank, replace and tighten DEF cap.
NOTICE:
DO NOT use agriculture grade urea solutions. DO
NOT use any fluids that do not meet “ISO 22241-1”
requirements in SCR emissions reduction systems. Use of
these fluids can result in numerous problems including
damage to SCR equipment and a reduction in NOx
conversion efficiency.
NOTE:
DEF level is shown on electronic display panel.
Use caution when dispensing DEF near an engine that has recently been
running. Spilling DEF onto hot components may cause the release of ammonia
vapors. DO NOT breathe ammonia vapors. DO NOT clean up any spills with
bleach.
1