Linde T 16, Руководство по эксплуатации

Страница: 19 / 53

3
6
0
8
0
4
2
5
1
1
-
0
5
0
4
4
3
CEE
GB
CH
US-C
1
2
Daily checks and commissioning checks
Charging the battery with the built-in char-
ger ( from 07/2000 )
Every day the truck is used normally, or every two days in
case of non-intensive use, charge the battery at the end of
the shift.
-
Park the truck near a socket outlet (220 V – 10/16 A).
- Lower the forks, turn off the key switch, remove the key.
- Open the battery compartment cover (1) for good ventila-
tion.
- Remove the plug (2) from its port , pay out the wire and
connect the plug to the mains.
- The charger starts automatically, the green light (3)
flashes, the red light (4) comes on and then goes off and
the charger fan is switched on.
- At the end of the normal charge, the green light remains
continuously on, and the fan stops.
- An equalization charge starts automatically 15 minutes
later; the green light remains on and the fan is switched
on.
- If the charger remains connected to the mains power
supply, it will restart a charge holding cycle every 48
hours, and the green light flashes.
Commissioning
WARNING:
Do not disconnect the battery connector while
charging (green light flashing).
Problems while charging
If a fault occurs while charging, the red light (4) comes on
and the charger stops.
Proceed as follows to resume a charge cycle after detection
of an anomaly:
-
Disconnect the mains power supply
- Unplug the battery connector for at least 1 minute
- Reconnect the battery connector, and then plug the mains
power supply in.
Please call one of our dealers if the problem persists.
Putting the mains power supply cable away
- Stow the cable in the compartment between the battery
box and the chassis.
- Push the mains plug (2) on the cable into the red safety
support in the battery compartment.
- C lo se th e c ov er .
IMPORTANT
The truck will operate only if the plug is replaced correc tly.
Charger electrical specifications
Mains power supply 220 V 50 Hz*Nominal battery voltage
24 V
Maximum output power 720 W Maximum current 30 A
Charging time 12 h (240 Ah)
*Other voltages/frequencies available to suit electrical
mains power supply in different countries
Special case of Gel batteries
Batteries with a gel electrolyte must always be charged
using a special charger.
https://www.besttruckmanuals.com/