48
Feed pump runs constantly,
will not turn off
•
Turn off manual switch on feed
pump module
•
Manual switch in on or
service position
Display activates, but pump
will not run
•
Loose or broken pump
wire connection
•
Tanks are full (if equipped
with tank switch)
•
Check wiring at terminal block
inside Connect Controller Box
•
Check tanks–
system cannot
be started if tanks are full.
System runs, no product
water delivered to water
tanks, GPH bar graph shows
OK,
“
reject
”
LED activated
•
High salinity of product
water, causing system to
reject water
•
Salinity probe out of
calibration or defective,
bad cable
•
Chlorine damage to
membranes
•
Pressure relief valve open
•
Check for low feed pressure
•
Check for leaks at high pressure
hoses
•
Test product water with hand
-
held
tester–
if over 500 PPM for 1 hour,
contact factory
•
Close pressure relief valve
No lights or display, system
does not operate
•
Remote display not
connected
•
No power to control box
•
Check display cable connections at
back of display and at control box
•
Check and reset main DC supply
breaker
•
Check for voltage (12 or 24 VDC) at
control box power input studs
•
Try manual toggle switch: If pump
runs, then control or display is defec-
tive
System runs, no product
water delivered to water
tanks, GPH bar graph
shows OK,
“
Good
”
LED
activated
•
Diversion valve inoperative
or wiring fault.
•
Disconnected or broken
product tubing
•
Diversion valve plunger
stuck
•
Check wiring at diversion valve and
inside control box
•
Check product tubing
•
Disassemble and clean diversion
valve plunger or replace valve
Feed pump runs with loud
noise
•
Intake blocked
•
Air in system
•
Check thru
-
hull valve
•
Check sea strainer for leaks
•
Check fresh water flush module for
leaks
•
Re
-
prime system (restart)
Troubleshooting
Catalina Systems
SYMPTOMS
PROBABLE CAUSE
REMEDY
Содержание Spectra Catalina 340C
