Club Car 2005 Precedent, Техническое обслуживание и сервис

Страница: 148 / 212

BATTERIES Battery Charging
Page 13-4 2005 Precedent IQ System Electric Golf Car Maintenance and Service Manual
13
Electrolyte Level, Continued:
The electrolyte level should be checked weekly to be sure electrolyte is at its proper level (Figure 13-2,
Page 13-3) . Never allow the electrolyte level to fall below the tops of the plates because this will cause the
exposed part of the plate to become permanently inactive. For best results, use a battery watering gun to add
water to batteries. Check the electrolyte level more frequently in hot weather or when batteries are old.
MINERAL CONTENT
For the longest battery life, use distilled water in batteries. However, if tap water is to be used, be sure the min-
eral contents are below these levels:
VIBRATION DAMAGE
The battery hold-downs should always be tight enough to keep the battery from bouncing. Battery life may be
severely shortened if the battery hold-downs are too loose. Battery hold-downs should be tightened to 97 in-lb
(11 N·m). Excessive vibration causes the plates to shed prematurely and shortens the life of the battery. It
may also cause acid to leak out of the vent caps and corrosion to build up on surrounding metal parts. The
acid which is lost reduces the capacity of the battery and cannot be replaced. Battery hold-downs should NOT
be so tight as to crack or buckle the battery case. This may cause leaks which would dry out a cell or cause
internal short circuits.
See Battery Replacement on page 13-1.
BATTERY CHARGING
See General Warnings, Section 1, Page 1-1.
The charger supplied with the Club Car electric vehicle resolves the most common problems associated with
battery charging. Undercharging and overcharging are prevented provided the charger is allowed to shut off
by itself. Also, all cells are automatically given an equalization charge at low current, which prolongs battery
life. Batteries should never be left in a discharged state, as this too affects the internal components and can
reduce the capacity of the battery. The batteries should be charged every day they are used. However, the
batteries should not be charged if they have not been used.
IMPURITY
ALLOWABLE CONTENT
(PARTS PER MILLION)
Suspended matter Trace
Total solids 100.0
Calcium and Magnesium
Oxides
40.0
Iron 5.0
Ammonia 8.0
Organic matter 50.0
Nitrates 10.0
Nitrites 5.0
Chloride 5.0