Troubleshooting Guide
26
Troubleshooting
Guide
Glossary of Problems:
1.
Pump motor does not run.
2.
Pump continues to run with switch in neutral.
3.
Pump will not lower.
4.
Plow will not raise or raises slowly, motor runs.
5.
While trying to raise the plow, blades extend and wings will not retract.
6.
Wings drift back when extended.
7.
Plow lowers too fast.
8.
Wing(s) will not extend, but motor runs.
9.
Wing(s) will extend, but will not retract or retract slowly.
10.
Wing(s) retract too easily while plowing.
11.
Oil leaks from cylinders.
12.
Battery goes dead with all switches in neutral.
13.
Plow lights are dim, will not come on or flicker.
14.
Turn signals flash at a rapid rate.
15.
High beam indicator light not functioning properly.
16.
Blade digs into the ground in the V position.
17.
Blade does not lay flat against the ground in the scoop position.
18.
Blade trips too easily.
19.
Plow does not clean-up snow from low areas.
20.
Oil runs out of fill cap of hydraulic pump.
21.
Pump chatters when raising the plow or extending wings.
22.
SmartHitch2 will not attach plow.
23.
Plow lights and truck lights are on at the same time.
24.
Plow and truck High and Low beam lights are on at the same time.
25.
Plow High beam and Low beam are on at the same time.
PROBLEM
DIAGNOSTIC CHECK
RESULT
1. Pump motor does not
run.
Check that power/ground
cables and control cables
are connected properly.
Connect.
Check for voltage at pump
motor while ignition switch
is on and LIFT control
button is pushed.
If voltage is present, pump
motor has failed or pump
has seized. Motor brushes
may be replaced, otherwise
replace pump/motor
assembly.
Check for power to the
solenoid by testing for
voltage between both
large terminals and
ground.
If voltage is not present
between one large terminal
and ground, the cable
between the battery and
solenoid is disconnected or
broken.
Содержание SMARTHITCH2 RT3 POWER-V
Страница 3: ...Snowplow Mounting Procedure 3 Figure 1 Mounting and Removal Instructions MSC04606 ...
Страница 15: ...Electrical System Wiring Schematic Plow Side 15 Figure 24 Electrical System Wiring Schematic Plow Side G10271 ...
Страница 17: ...Electrical System Wiring Diagram 17 Figure 26 Electrical System Wiring Diagram G10134 ...