Alligator Gatorbrake 6 Piston, Инструкция по установке и обслуживанию

Страница: 6 / 39

Warning: We strongly recommended that only competent cycle
mechanics install and service your disc brake system. Always
wear protective clothing, safety glasses and gloves when
servicing this system.
Warranty
Gatorbrake Six Piston disc brakes are warranted for a period of one full year from the original purchase against
defects in material and workmanship. The warranty only applies to original owner, cannot be transferred and proof
of purchase is required. No warranty claim can be processed until the product has been returned to the factory.
Any Gatorbrake products that are returned to the factory and are found to be defective in materials or
workmanship will be replaced or repaired at its option. This warranty does not cover damage caused through
misuse, incorrect assembly, modifying the system or failure to follow this manual or service instructions.
Gatorbrake or Alligator shall not be held liable for any indirect, special or consequential damages.
Symptoms Possible Cause Corrective Action
Lever goes to the handlebar
System leak
Air in the System
Brake pads worn out Re-bleed the system
Re-bleed the system
Replace pads
Spongy Lever Air in the system Re-bleed the system
Disc Rotor rubbing on the Pads
Caliper not centered over
disc
Inadequate clearance
Bent rotor
Re-center the caliper
Push piston back
Replace new rotor
No braking power
Contaminated pads
Worn out pads
Contaminated disc Replace new pads
Replace new pads
Clean disc with alcohol
Pads fall out Missing pin Replace pin
Fluid loss
Hose leaking
Banjo leaking
Caliper bleeding
Tighten hose nut
Replace new hose
Replace banjo O-ring
Tighten or replace bleeder
Troubleshooting
EN
Torque Chart
Nm in. lbs
Disc Screws 6 -7 53 - 63
Master Cylinder Clamp Screw 1.7 - 2.26 15 - 20
Caliper Bleeder 3 - 5 27 - 44
Caliper Mounting Bolts 11 - 13 97 - 114