FUEL INJECTION SYSTEM
9-37
6. Verify the operation of the sensor or actuator.
• Sensor operation
The data representing the operating conditions of the sensor appears on the multifunction meter.
• Actuator operation
Set the engine stop switch to “ON” to operate the actuator.
TIP
If the engine stop switch is set to “ON”, set it to “OFF”, and then set it to “ON” again.
7. Turn the main switch to “OFF” to cancel the diagnostic mode.
TIP
To perform a reliable diagnosis, make sure to turn off the power supply before every check and then
start right from the beginning.
Diagnostic code table
“d01 d70”
d01”
“d70
Fault
code
No.
Symptom
Probable cause of malfunction
Diagnostic
code No.
12
No normal signals are re-
ceived from the crankshaft
position sensor.
• Open or short circuit in wire harness.
• Defective crankshaft position sensor.
• Malfunction in crankshaft position sensor
rotor.
• Malfunction in ECU.
• Improperly installed sensor.
—
13
Intake air pressure sensor:
open or short circuit detect-
ed.
• Open or short circuit in wire harness.
• Defective intake air pressure sensor.
• Malfunction in ECU.
d03
14
Intake air pressure sensor:
hose line malfunction
(clogged or detached
hose).
• Intake air pressure sensor hose is de-
tached, clogged, kinked, or pinched.
• Malfunction in ECU.
d03
15
Throttle position sensor:
open or short circuit detect-
ed.
• Open or short circuit in wire harness.
• Defective throttle position sensor.
• Malfunction in ECU.
• Improperly installed throttle position sensor.
d01
16
Stuck throttle position sen-
sor detected.
• Stuck throttle position sensor.
• Malfunction in ECU.
d01
21
Coolant temperature sen-
sor: open or short circuit
detected.
• Open or short circuit in wire harness.
• Defective coolant temperature sensor.
• Malfunction in ECU.
• Improperly installed coolant temperature
sensor.
d06
Summary of Contents for Grizzly550
