MD Helicopters CSP-900RMM-2, Servicing And Maintenance

Page: 139 / 2144

CSP − 900RMM − 2 MD Helicopters, Inc.
Rotorcraft Maintenance Manual
Page 217
Revision 34
05-20-50
Table 204. Inspection 3 − Main Rotor and Upper Transmission Deck (Area 3 and 4) (Cont.)
Registration No. Serial No. Helicopter Total Hours
Model Initial RMM Section Requirement
Hydraulic System
900 Inspect hydraulic system tubes, flexible hoses, and pump case drain
hoses for leaks, indication of failure, security of connections, support,
and security of attach hardware.
29 − 00 − 00
900 Inspect System 1/System 2 manifold/reservoir for leaks, condition,
security. Do a check for correct fluid levels.
29 − 00 − 00
900 Inspect Ground Support Equipment (GSE) panel and interconnecting
tubes for leaks, condition, security of tube connections, support, and
security of attach hardware.
29 − 00 − 00
If optional hand pump is installed:
900 Inspect hand pump for leaks, condition, and security of installation. 29 − 00 − 00
900 Inspect interconnecting tubes for leaks, indication of failure, security
of connections, support, and security of attach hardware.
29 − 00 − 00
Powerplant
900 Inspect forward left and right engine tubes for fluid leaks, condition,
and security of connections and supports.
71 − 70 − 00
79 − 00 − 00
900 Inspect left and right forward engine firewall to plenum seals for
condition and security of fire − seal clamp.
71 − 00 − 00
900 Inspect left and right forward engine mounts for damage, condition,
indication of failure, and security of attach hardware.
71 − 20 − 00
If optional generator cooling modification is installed:
900 Do the Generator Cooling Duct and Screen Inspection. 71 − 60 − 00
Engine Controls
900 Inspect mechanical linkage to FMU for condition, correct installation,
and security of attach hardware.
76 − 00 − 00
900 Inspect mechanical engine control boxes, control cables, and adapter
plates for condition and correct installation.
76 − 00 − 00
NACA Inlet
900 Inspect NACA inlet for condition and security. 71 − 60 − 00
if Inlet Particle Separator is installed:
900 Inspect NACA inlet:
door for impact or other damage and condition of seal
door actuator for condition and security
door linkage for condition and security
electrical connector and wire harness for condition and security.
71 − 60 − 00