19
Electrical
HYDRAULIC ATTACHMENT SYSTEM
SOLENOID
1
2
4
3
1. Light Green (w34) – Positive [+] Terminal of Coil
2. Red – from Circuit Breaker
3. Copper Strap to Motor
4. Purple – Negative [–] Terminal of Coil
2246
Figure 19-30
Solenoid Wiring and Testing
Testing the Solenoid
1.
Test for continuity between the two small coil terminals (light green wire and purple wire)
2.
Test for no continuity between the two large terminals (red wire and copper strap)
.
3.
Apply 12 volts with the positive lead connected to the positive coil terminal and the negative lead connected to the
negative coil terminal. The solenoid should click and show continuity between the two large terminals.
Solenoid Removal
1.
Empty and raise cargo bed.
2.
Set the joystick ON/OFF switch to OFF.
3.
Disconnect battery.
See Disconnecting the Battery – Gasoline/Diesel Vehicles, Section 1, Page 1-3.
4.
Note wiring and disconnect wires and copper strap from solenoid.
5.
Remove screws securing solenoid to motor and remove solenoid.
Solenoid Installation
1.
Attach solenoid to motor with screws.
2.
Connect wires and copper strap to solenoid. Tighten hardware on the small terminals to 10 in-lb (1.1 N·m) and
21 in-lb (2.4 N·m) on the large terminals.
3.
Connect battery.
See Connecting the Battery – Gasoline/Diesel Vehicles, Section 1, Page 1-4.
4.
Lower the cargo bed.
CIRCUIT BREAKER
Testing the Circuit Breaker
1.
Check for continuity between each post.
2.
If there is no continuity, press the reset button and check again for continuity.
3.
If there is still no continuity, replace the breaker.
Circuit Breaker Removal
1.
Empty and raise cargo bed.
Page 19-18
2013 Carryall 295/XRT 1550 Maintenance and Service Manual
Summary of Contents for Carryall XRT 1550
