Club Car Carryall XRT 1550, Maintenance And Service Manual

Page: 172 / 432

11
Test Procedures
TROUBLESHOOTING AND ELECTRICAL
SYSTEM: GASOLINE VEHICLES
2089
Figure 11-25 Carburetor Solenoid Bullet Connector
TEST PROCEDURE 28 – Low Oil Warning Light Circuit
See General Warnings, Section 1, Page 1-2.
If the low oil warning light stays on, test the oil pressure switch. See the Kawasaki FH680D engine manual (CC
P/N 103351201). If the low oil warning light does not illuminate and the vehicle is low on oil, proceed to step 1. See
following NOTE.
NOTE: The low oil warning light should illuminate when the key switch is turned to the ON position. After the engine
has been started, the low oil warning light should remain illuminated until the oil pressure switch has been
activated.
1. Disable the vehicle. See Disabling the Vehicle on page 1-3.
2. Raise the hood.
3. Ensure that the wires on the oil warning light are connected correctly and are tight. If they are not, rewire
or tighten as necessary.
4. Disconnect the 18-gauge blue/white wire (w17) from the low oil warning light terminal.
5. Leave the 18-gauge purple wire (w42) connected to the low oil warning light.
6. Place a jumper wire on the terminal of the low oil warning light where the blue/white wire (w17) was removed.
7. Touch the frame (ground) with the remaining end of the jumper wire.
8. Turn the key switch to the ON position. The low oil warning light should illuminate.
9. If the low oil warning light does not illuminate when the key switch is in the ON position, check the 18-gauge
purple wire (w42) for continuity between the terminal at the low oil warning light and the 18-gauge purple wire
(w47) at the key switch. Also check the continuity between the terminal on the 18-gauge blue/white wire (w17)
and the terminal on the engine 6-pin connector brown wire (w146).
10. If there is continuity between the 18-gauge purple wire (w42) at the low oil warning light and the 18-gauge purple
wire (w47) at the key switch, replace the low oil warning light. See Warning Light Removal on page 13-6.
11. If the problem is not corrected by performing the previous steps, test the oil pressure switch. See the Kawasaki
FH680D engine manual (CC P/N 103351201).
Page 11-30 2013 Carryall 295/XRT 1550 Maintenance and Service Manual