Discharge Valve
2.
Push handle in and pull
upwards to open.
MIX LIFT
OFF
Mixing
1.
Turn MIX/LIFT SWITCH (
14
) to
"MIX".
2.
Turn MIXER SPEED
CONTROL (
10
) to "MIN" and
slowly adjust to desired
speed.
3.
Adjust SECONDARY SPEED
CONTROL (
22
) to desired
speed.
UP DOWN
OFF
MIX LIFT
OFF
Lifting & Lowering
Bridge
WARNING-
Insure FAUCET
SPOUT (
15
) is out of way before
raising or lowering bridge.
1.
Turn MIX/LIFT SWITCH (
13
) to
"LIFT".
2.
Turn MIXER SPEED
CONTROL (
10
) to "MIN" and
back up to #5.
3.
Turn and hold UP/DOWN
SWITCH (
14
) "UP" to raise or
"DOWN" to lower.
Adding Water
Manually
1.
Locate FAUCET SPOUT (
15
)
over desired kettle.
2.
Turn on HOT or COLD WATER
VALVES (
16
or
17
).
OFF ON
General Operation
1.
Turn MAIN POWER SWITCH
(
12
) to "ON".
OPERATING SUGGESTIONS
Cleveland Range Mixer Kettles are simple and
safe to operate. The following tips will allow you to
maximize the use of your new mixer.
1.
Allow unit to preheat before addition of product to
kettle. However when cooking egg and milk
products, the kettle should NOT be preheated, as
products of this nature adhere to hot cooking
surfaces. These types of foods should be placed
in the kettle before heating is begun.
2.
An important part of kettle cleaning is to
prevent foods from drying on. For this reason,
cleaning should be completed immediately
after cooked foods are removed.
3.
If a mixer bridge is equipped with a
temperature probe for a controller or
thermometer, the probe must be submerged a
minimum of three inches in the product for
accurate readings.
Safety
1.
Close BUTTERFLY VALVE (
9
) before filling the
kettle.
2.
When raising or lowering MIXER BRIDGE (
18
),
insure FAUCET SPOUT (
15
) is not in the way
of MAIN AGITATOR ARM (
19
) or damage to
spout will result.
3.
As a safety precaution the MIXER SPEED
CONTROL (
10
) must first be turned to zero
before unit will start to mix.
4.
Always remember, like a cooking pot the
kettles become very hot when cooking. Avoid
contact with bare skin.
Tilting Kettle
1.
Raise MIXER BRIDGE (
18
)
and swing to side.
2.
For
manual tilt:
turn TILT
WHEEL (
8
).
3.
For
power tilt:
turn switch
" " to raise, or " " to tilt.
WARNING-
Do not tilt kettle
when mixer agitators are in kettle
bowl.
