1-14
2006 Buell Lightning: Maintenance
HOME
Replacing Oil
1.
Inspect drain plug o-ring for tears or damage. Replace if
required. Wipe any foreign material from drain plug.
2.
Apply Loctite 565 Thread Sealant, reinstall plug and
tighten to 29-34 ft-lbs (40-46 Nm).
3.
Fill oil tank through filler (dipstick) hole with recom-
mended oil from
Table 1-5.
Oil tank capacity with filter
change is approximately 2.5 quarts (2.4 liters) and
includes the 4.0 ounces (0.12 liter) poured into the filter.
Always verify proper hot oil level on dipstick. Do not over-
fill.
4.
Inspect o-ring on dipstick for rips or tears. Replace as
required.
NOTE
For ease of installation, apply a light film of clean engine oil to
the dipstick o-ring.
5.
Install dipstick into oil tank/swingarm fill hole. Make sure
dipstick is installed completely. DO NOT OVER
TIGHTEN.
6.
Remove left side oil cooler scoop. See
2.38 AIR
SCOOPS
.
7.
Inspect oil cooler fins for debris or damage. Blow out any
debris from fins with compressed air from the inside of
the cooler outward.
8.
Wipe up any spilled oil on muffler.
9.
Start engine. Verify that oil pressure signal light on instru-
ment support turns off after a few seconds when engine
speed is 1000 RPM or above.
10. Check for oil leaks at oil filter, drain plug, hoses and oil
cooler.
11. Install chin spoiler. See
2.36 CHIN FAIRING
.
12. Install air scoop
2.38 AIR SCOOPS.
13. Check (hot) oil level. See
CHECKING ENGINE OIL
LEVEL
.
Table 1-5. Recommended Oil Grades
HARLEY-DAVIDSON TYPE
VISCOSITY
HARLEY-DAVIDSON
RATING
LOWEST AMBIENT TEMP
°F
COLD WEATHER
STARTS BELOW
50° F
H.D. Multi-Grade
SAE 10W40
HD 360
Below 40
°
(4°C)
Excellent
H.D. Multi-Grade
SAE 20W50
HD 360
Above 40
°
(4°C)
Good
H.D. Regular Heavy
SAE 50
HD 360
Above 60
°
(16°C)
Poor
H.D. Extra Heavy
SAE 60
HD 360
Above 80
°
(27°C)
Poor
Summary of Contents for 2006LIGHTNING MODELS
