Boston Whaler 210 Montauk, Owner'S Manual

Page: 77 / 113

3-8 210 Montauk
Section 3 • Systems & Components Overview & Operation
R
ATTENTION
The seacock must be in the open position when
livewell is in use. Running the pump dry may
cause damage to the unit.
Maintenance
Maintenance of the livewell system will require you
to check the seacock intake strainer for debris and
impediments, this can be done visually on dry land.
The intake strainer is located on the bottom aft of the
hull on the port side.
Reversible Pilot Seat Livewell (Option)
If equipped, the optional 25 Gal. (94.6 L) livewell
is located in the reversible pilot seat under the seat
cushion. This livewell can be filled by pressing the
“LIVEWELL” switch on the optional switch panel
located on the console (See fig. 2.13.2). The livewell
bucket has an overflow fitting attached to the drain.
Be sure the hull seacocks are in the open position. The
seacocks can be reached by removing the motorwell
hatch. Turn the seacock counterclockwise to OPEN.
Proper maintenance of this system will ensure worry-
free usage for the life of your boat.
Steering system integrity is imperative when
engaging in recreational water activities. Special
care and attention must be taken to ensure proper
performance of the steering system and should
include the following:
• After the first few hours of operation and
at regular intervals, check all fasteners and
the complete steering system .
• Check all moving parts to be sure they
are free of salt build-up and other foreign
material. Such build-up will affect their
operation and cause steering problems.
Periodically remove the cable, clean the
hinge tube thoroughly, and lubricate with a marine
type waterproof grease.
• Inspect for corrosion. Check for full range
of motion while steering or sluggishness
while steering. Any part effected by corrosion
must be replaced. When replacing parts, self
locking hardware MUST be used.
REFER TO MANUFACTURER’S MANUAL IN YOUR
OWNER’S MANUAL PACKET FOR COMPLETE
INSTRUCTIONS AND WARRANTY.
Do not cover cracks in the steering cable or
fittings with tape or other sealants. This will
create a hazard in which the cable can fail
without warning.
!
CAUTION
NOTICE
The system does not eliminate engine torque.
This can only be accomplished by proper trim
and tilt settings.
Deluxe Leaning Post Livewell (Option)
If equipped, the optional 30 Gal. (113.6 L) livewell
is located in the deluxe leaning post. This livewell
can be filled by pressing the “LIVEWELL” switch
NOTICE
The thru-hull drain/seacock (See fig. 3.9.1)
MUST be in the OPEN to avoid livewell from
overflowing.
Make a habit of checking the fluid level before each
trip. Proper maintenance of this system will ensure
worry-free usage for the life of your boat. Steering
system integrity is imperative when engaging in rec-
reational water activities. Special care and attention
must be taken to ensure proper performance of the
steering system and should include the following:
• After the first few hours of operation and at
regular intervals, check all fasteners and the
complete steering system for security and
integrity.
• Inspect for corrosion. Any part affected by
corrosion must be replaced.
• When replacing parts, self locking hardware
must be used.
• Check the fluid level in the helm pump unit.
• Lubricate slides on the engine cylinders.
All steering systems whether mechanical or hydraulic
require regular inspections, periodic adjustment and
occasional replacement may be necessary.
Maintenance