5-4 Generator Maintenance/Service
450 LXi
Owner Manual
~ 5-4-10 ~
Rev. “C”
(1) Air cleaner body
(2) Element
(3) Wing bolt
(4) Evacuator valve
Since the air cleaner employed on this engine is a dry type, never apply oil to it.
Open the evacuator valve once a week under ordinary conditions - or daily when
used in a dusty place. This will get rid of large particles of dust and dirt.
Wipe the inside air cleaner clean with cloth if it is dirty or wet.
Avoid touching the element except when cleaning.
When dry dust adheres to the element, blow with compressed air from the inside
turning the element. Pressure of compressed air must be under 686kPa (7kgf/
cm2, 99psi).
When carbon or oil adheres to the element, soak the element in detergent for 15
minutes, then wash it several times in water, rinse with clean water and let dry
naturally.
1.
2.
3.
4.
5.
5-4.7 Air Cleaner
After the element is fully dried, inspect the inside of the element with a light, and check if it is damaged or not, (referring
to the instructions on the label attached to the element.)
Replace the element every year or every 6 cleanings.
6.
7.
!!IMPORTANT:
Make sure the wing bolt for the element is tight enough. If it
is loose, dust and dirt may be sucked in, wearing down the
cylinder liner and piston ring earlier, and thereby resulting in
poor power output.
Do not over service the air cleaner element. Over servicing may
cause dirt to enter the engine causing premature wear. Use
the dust indicator as a guide for when to service.
•
•
5-4.7.1 Dust Indicator
(optional)
If the red signal on the dust indicator attached to the air cleaner is visible,
the air cleaner has reached the service level.
Clean the element immediately, and reset the signal with the “RESET”
button.
(1) “RESET” button
(2) Dust indicator
(3) Service level
(4) Signal
5-4.8 Battery
Mishandling of the battery shortens the service life and adds to maintenance costs. To obtain the maximum performance
and the longest life of the battery handle properly and with care.
CAUTION!!
To
avoid
personal
injury:
Be careful not to let the battery electrolyte contact your body or clothing.
Wear eye protection and rubber gloves, since the diluted sulfuric acid solution burns skin and eats holes in clothing.
Should this occur, immediately wash it off with running water and seek medical attention.
•
•
Engine starting will be more diffi cult, if the battery charge is low. Be careful to recharge before it gets too low.
Summary of Contents for 450 LXi
