INSTRUCTIONS FOR USE
AGS 400-1200 EN
Rev.12/2018
88
Some insecticides contain solvents which affect the paint. Clean the corrosion off of colourless parts of
the spraying equipment and apply some new paint.
15.4
SIGNAL LIGHTS
Signal lights are installed at the back side of the spray boom. It is equipped with two reflective boards
(RED-WHITE), rear lights with a reflective triangle and two white reflectors installed at the front of
the boom set. The power cable with a plug is directed to the cab of the tractor.
The components of signal lights are shown in Figure 92.
Figure 13: Signal lights
15.5
CLEANING THE SPRAYING DEVICE
After every single use of the sprayer, the appliance must be thoroughly cleaned. The best way to use
any excess insecticide is to dilute it with water and spray it on the same surface again. The
concentration should be at least 10% (10 units of water per one unit of insecticide), the spraying speed
slightly faster and the spraying pressure slightly lower (1.5 bar, depending on the nozzle). While doing
this, use the additional reservoir for washing. The procedure is described in the chapter 7.11.2. After
that, thoroughly clean the sprayer on the inside and the outside and also clean all tolls which you have
used for spraying (including the tractor). Use only detergents that are recommended by the
manufacturer of protection agents! If there are instructions for cleaning of the appliance after using it
attached to the instructions for using the insecticide, follow them.
In accordance with the local legislation on washing of the pesticides into the earth, agree on cleaning
of your sprayer with your advisory service.
The ablution of pesticides (cleaning of the sprayer) must not be performed on swampy ground or in the
near of streams, water dams, dykes or water fountains, etc.
If there is still some insecticide inside the sprayer and if you had to stop working unexpectedly for
some time it is recommended to clean the pump, the regulator and the spraying lining with clean water
(see chapter 7.9.3).
In the case you had to stop working unexpectedly but did not clean the sprayer yet, you have to
assure that other people or animals cannot reach the sprayer.
