-7-
3)Close rubber plug
of oil filler after finishing lubrication.
①
Caution:
1.To prevent the unexpected startup of sewing machine, trim off the power supply
before the operation is conducted.
2.when using the new sewing machine for the first time, open the rubber plug
① of o
-il filler and fill with 200ml oil.(No.10 white oil)
旋梭油量调节 (图
7
、图
8
、图
9
)
Oil mass Adjustment of Rotating Hook (Fig. 7 , Fig. 8 , Fig. 9)
7
1.调节方法
1)旋梭的油量是用旋梭油量调节螺钉①来
调节:拧紧(向右转动)旋梭油量调节螺钉①旋梭
油量将增多,拧松(向左转动)旋梭油量将减少,
直至获得适当的供油量为止。
1.Adjustment method
1)
Adjusttheoilmassofrotatinghookusing
adjusting screw ①: Screw down (turn it to the
right) adjusting screw ① to raise the oil mass
,or unscrew (turn it to the right) the adjusting
screw to lower the oil mass.Amount repeate
-dly until the lubrication amount is correct.
2)调节油量后缝纫机在进行约2小时的缝纫
后,再次检查以确认供油量。
注意:
1.为了防止缝纫机的意外启动,请关掉
电源之后再进行操作。
2
)Check the lubrication amount again after
the sewing machine has been used for appr
-oximatelytwohours.
Caution:
1.To prevent the unexpected startup
of sewing machine, trim off the pow
er supply before the operation is co
-nducted.
2.油量的确认方法
1)拆去挑线杆至机针上的面线。
2)点击触摸屏上抬压脚按键抬起压脚。
3)以缝纫机实际缝纫时的转速进行约3分钟
的空运转(适度的断续运转)。
4)将油量测试纸②插入旋梭③的下面并握
住,以缝纫机实际进行缝纫时的转速使缝纫机
运转10秒钟。(对油量测试纸②的纸质没有什么
特别的要求)
5)确认飞溅到测试纸②上的油量。
2.Confirming the Oil Mass
1) Remove the thread from all points from
the thread take-up to the needle.
2) Click the presser foot button to raise the
3) Run the machine at the normal sewing sp
-eed for approximately 3 minute without sewi
-ng any material (following the same start/sto
-p pattern as when actually sewing)
4) Place the lubrication amount check sheet
②
underneaththerotaryhook
③
andholdit
there.Then run the sewing machine at the normal sewing speed for 10 seconds.(Any type
of paper can be used as the lubrication amount check sheet ②)
5) Check the amount of oil which has spattered onto the sheet
②.
presser foot.
Содержание A9200L-D4-W-CP
Страница 1: ...直驱高速平缝机 A9200L D4 W CP系列 DIRECT DRIVE HIGH SPEED LOCKSTITCH SEWING MACHINE ...
Страница 40: ...5 9 11 17 15 19 21 23 ...
Страница 41: ...A 2 A 6 A 6 A 11 A 12 A 13 A 14 A 15 A 15 A 15 A 39 A 40 A 41 A 42 ...
Страница 65: ......