FLASHBAKE
®
/ MICROWAVE OVEN GENERAL
Form 24694 (April 2001)
Page 4 of 52
RADIATION SAFETY INSTRUCTIONS
PRECAUTIONS TO BE OBSERVED BEFORE
AND DURING SERVICING TO AVOID POSSIBLE
EXPOSURE TO EXCESSIVE MICROWAVE
ENERGY.
1.
Do not operate or allow the oven to be
operated with the door open.
2.
Make the following safety checks on all ovens
to be serviced before activating the magnetron
or other microwave source, and make repairs
as necessary:
A.
Interlock operation.
B.
Proper door closing.
C.
Seal and sealing surfaces (arcing, wear,
and other damage).
D.
Damage to or loosening of hinges and
latches.
E.
Evidence of dropping or abuse.
3.
Before turning on microwave power for any
service test or inspection within the microwave
generating compartments, check the
magnetron, wave guide or transmission line
and cavity for proper alignment, integrity, and
connections.
4.
Any defective or misadjusted component in the
interlock, monitor, door seal, and microwave
generation or transmission systems shall be
repaired, replaced, or adjusted by procedures
described in this manual before the oven is
released to the owner.
5.
A microwave leakage check to verify
compliance with the Federal Performance
Standard should be performed on each
oven prior to release to the owner.
GENERAL
INTRODUCTION
General
The combination FlashBake
®
and microwave oven
cooks the outside of foods much like conventional
radiant heat, while also penetrating the surface so
the inside cooks simultaneously. While halogen light
is the primary source of power, a “microwave boost”
is added with certain foods. Foods cook evenly and
fast, retaining their natural moisture.
Oven features:
•
Turntable rotates to ensure even cooking.
•
Halogen lamps; two 1500 watt lamps cook from
the top and one 1500 watt lamp cooks from the
bottom.
•
Microwave “boost” is automatically added with
certain foods.
•
Oven can also be used as a 950-watt
microwave oven.
•
Voltage Compensation: Line voltage is
monitored by the voltage compensation
transformer on the control board. It monitors
voltage from L2 to neutral at the start of each
menu cook selection and adjusts the cooking
time to achieve quality results.
The optimal line voltage of 120VAC has no
compensation. Above 120VAC, time is
subtracted from the recipe (up to -30 sec.).
Below 120VAC, time is added to the recipe (up
Содержание VFBMW
