2 - 2
2 Troubleshooting
Troubleshooting Chart
WARNING
Before beginning any service work, turn the PTO
off, set the parking brake, turn the ignition switch
off, remove the key. Disconnect the spark plug
wire on gas engine models, and disconnect the
negative battery cable.
Never attempt to perform repairs while the engine
is running.
Failure to comply with this and other safety
requirements can result in serious personal
injury.
TROUBLESHOOTING
The troubleshooting guide below lists some common
problems, their causes, and remedies.
See the repair information in the following sections for
instructions on how to perform most of these minor
repairs yourself. If you prefer, all of these procedures
can be performed for you by your local authorized
dealer.
TROUBLESHOOTING THE TRACTOR
PROBLEM
CAUSES
REMEDIES
SEE SECTION
Engine will not
1. Cruise control lever engaged.
Disengage cruise control.
N/A
turn over or start.
2. PTO (electric clutch) switch
Place in OFF position.
N/A
in ON position.
3. Out of fuel.
If engine is hot, allow it to cool, then refill
3
the fuel tank.
4. Engine flooded.
Move choke control out of CHOKE position.
N/A
5. Circuit breaker tripped/blown
Wait one minute for automatic reset.
7
fuse.
Replace if defective. Replace blown fuse.
6. Battery terminals require
Clean battery.
3, 7
cleaning.
7. Battery discharged or dead.
Recharge or replace.
6, 7
8. Wiring loose or broken.
Visually check wiring and replace broken or
7
frayed wires. Tighten loose connections.
9. Solenoid or starter motor faulty.
Repair or replace.
See Engine Manual
10.Safety interlock switch.
Replace as needed.
7
11.Spark plug(s) faulty, fouled,
Clean and gap or replace.
See Engine Manual
or incorrectly gapped (gas only).
12.Water in fuel.
Drain fuel and refill with fresh fuel.
N/A
13.Fuel is old or stale.
Drain fuel and replace with fresh fuel.
N/A
14.Foot pedal not fully depressed.
Depress pedal.
N/A
Engine starts hard
1. Dirty Air Filter
Replace Air Filter
See Engine Manual
or runs poorly
2. Fuel mixture too rich.
Clean air filter.
See Engine Manual
(gas only).
3. Using old/stale gas.
Drain fuel and replace.
N/A
4. Spark plug(s) faulty, fouled, or
Clean and gap or replace.
See Engine Manual
incorrectly gapped.
Engine starts hard
1. Dirty air filter.
Replace air filter.
See Engine Manual
or runs poorly
2. Fuel is contaminated.
Drain fuel and replace with fresh fuel.
See Engine Manual
(diesel only).
3. Fuel filter plugged.
Drain water or replace filter.
See Engine Manual
4. Wrong fuel type for season.
Drain fuel and replace with fresh fuel
See Engine Manual
of proper grade; clean or replace filter.
Engine knocks
1. Low oil level.
Check/add oil as required.
3
(gas only).
2. Using wrong grade oil.
See engine manual.
Excessive oil
1. Engine running too hot.
Clean engine fins, blower screen and
See Engine Manual
consumption.
air cleaner.
2. Using wrong weight oil.
See engine manual.
3. Too much oil in crankcase.
Drain excess oil.
3
Engine exhaust
1. Dirty air filter.
Replace air filter.
See Engine Manual
is black (gas only).
2. Choke closed.
Open choke.
N/A
Engine runs, but
1. Two-speed Hi/Low control
Shift into gear.
N/A
tractor will not drive.
in neutral.
Brake will
1. Brake is incorrectly adjusted.
Adjust brake.
4, 12
not hold.
2. Brake pads worn.
Replace brake pad assembly.
12
Not
for
Reproduction
Содержание AGCO Allis 2000 Series
