USER MANUAL
ENGLISH
RS 851
33018305(3)2010-01 A
39
ENGINE RADIATOR FIN CLEANING CHECK
Empty the hopper (7, Fig. G); if it contains a small quantity of waste, it is not necessary to dump it.
1.
Drive the machine on a solid and level ground, then engage the parking brake (13, Fig. E).
2.
Lift the hopper (7, Fig. G), according to the procedure shown in the relevant paragraph.
3.
Turn the ignition key (24, Fig. D) to OFF position and remove it.
4.
To avoid that the hopper lowers by accident, install the lifted hopper support rods (3, Fig. F), according to the instructions
5.
shown on the relevant paragraph.
Close the left and right side upper doors (9 and 28, Fig. G) by engaging the fasteners (10) and (29) with the supplied key.
6.
Remove the screws, then remove the engine compartment panel (11, Fig. F).
7.
Open the left side lower door (11, Fig. G) by disengaging the fastener (12) with the supplied key.
8.
Check the radiator
fi
n cleaning as shown in the diesel engine Manual.
9.
Perform steps 3 to 8 in the reverse order.
10.
ENGINE COOLANT LEVEL CHECK
Engage the parking brake (13, Fig. E).
1.
Turn the ignition key (24, Fig. D) to OFF position and remove it.
2.
With a suitable ladder, reach the coolant tank (5, Fig. G).
3.
WARNING!
The coolant line is pressurized; do not perform any check until the engine has cooled down and, even if the
engine is cold, the tank plug (2, Fig. AQ) must be opened with extreme care.
Check that the coolant level in the tank (1, Fig. AQ) is between the minimum and maximum marks, as shown in the diesel
4.
engine Manual. If necessary, unscrew the plug (2) and top up.
Coolant components:
5.
50% of AGIP antifreeze
•
50% of water
•
After top up, tighten the plug (2, Fig. AQ).
6.
ENGINE FUEL FILTER REPLACEMENT
Engage the parking brake (13, Fig. E).
1.
Turn the ignition key (24, Fig. D) to OFF position and remove it.
2.
Open the right under-cab door (31, Fig. G) by disengaging the fastener (32) with the supplied key.
3.
Open the right side lower door (34, Fig. G) by disengaging the fastener (35) with the supplied key.
4.
Replace the fuel
fi
lter (1, Fig. AP) as shown in the diesel engine Manual.
5.
Perform steps 3 to 5 in the reverse order.
6.
FUEL PRE-FILTER REPLACEMENT
Engage the parking brake (13, Fig. E).
1.
Turn off the engine, by turning the ignition key (24, Fig. D) counterclockwise, to the end of stroke, then remove it.
2.
Open the right side upper door (28, Fig. G) by disengaging the fasteners (29) with the supplied key.
3.
Open the right side lower door (34, Fig. G) by disengaging the fastener (35) with the supplied key.
4.
Replace the fuel pre-
fi
lter (44, Fig. F) by loosening the clamps (2, Fig. AV) and by removing the hose (1) from the
fi
ttings on the
5.
element (3). Pay attention to the fuel that spills out during this procedure.
Replace the
fi
lter element (3, Fig. AV).
6.
Perform steps 3 to 5 in the reverse order.
7.
CAB AIR FILTER REPLACEMENT
Empty the hopper (7, Fig. G); if it contains a small quantity of waste, it is not necessary to dump it.
1.
Drive the machine on a solid and level ground, then engage the parking brake (13, Fig. E).
2.
Lift the hopper (7, Fig. G), according to the procedure shown in the relevant paragraph.
3.
Turn the ignition key (24, Fig. D) to OFF position and remove it.
4.
To avoid that the hopper lowers by accident, install the lifted hopper support rods (3, Fig. F), according to the instructions
5.
shown on the relevant paragraph.
Open the left side upper door (9, Fig. G) by disengaging the fastener (10) with the supplied key.
6.
With a suitable ladder, loosen the screw (1, Fig. AS) and turn the retainer (2).
7.
Remove the cab air
fi
lter (1, Fig. AT).
8.
Install the new
fi
lter (1, Fig. AT) with the arrows (2) pointing in the direction of the air
fl
ow (upwards).
9.
Perform steps 3 to 7 in the reverse order.
10.
Содержание 13300113
