IC Bus Gasoline CE Series, Руководство по эксплуатации и обслуживанию

Страница: 17 / 241

Introduction
Drive vehicle monthly to exercise the brakes, driveline and
steering. Run the vehicle long enough for the engine to reach
operating temperature.
NOTE: Losses occurring to a unit while it is in storage will
not be considered for warranty reimbursement.
Storage Duration – One Month or Less
1. Wash vehicles as necessary. Always wash vehicles that
have been exposed to road salt.
NOTE: Washing Instructions - Wash the vehicle with warm
water and mild soap, then wipe wet surfaces with a chamois
or soft cloth. DO NOT use hot water or strong soaps or
detergents. DO NOT wash the vehicle in direct sun, or when
the sheet metal is hot to the touch. This will streak the finish.
DO NOT wipe dirt off dry surfaces, as this will scratch the
finish.
NOTE: When vehicles are stored outside, particularly in
coastal areas (salt water and high humidity atmosphere)
or other areas of corrosive environment, paint and bright
metal may require frequent washing and waxing to prevent
deterioration.
Determining washing frequency is the
customer's responsibility.
NOTE: For vehicles exposed to ultraviolet rays of the sun,
apply a coating of Bon-Ami
® soap, or similar product, to the
inside surfaces of the windshield and windows, to shade the
interior and prevent fading of the interior trim.
2. Inspect painted surfaces; touch up all exposed primed or raw
metal areas to prevent rust.
3. Apply a thick coat of wax to prevent discoloration from the
elements; wax all chrome and stainless steel metal parts.
4. Check the radiator coolant for proper level and adequate
freeze protection (-20°F [-29°C] is standard for medium duty
models and bus chassis; -40°F [-40°C] is standard for heavy
duty models.)
5. Drain air brake reservoirs and close the drain cocks.
6. Lubricate all exposed transmission and auxiliary
transmission shift rails.
7. Check state-of-charge eye in batteries and re-charge if
open circuit voltage is below 12.6 volts. Disconnect battery
ground cables to prevent accidental starting, or parasitic
electrical loads from discharging the battery.
Storage Duration–Over One Month
Units in storage longer than one month should be driven until the
engine reaches operating temperature:
1. Make sure all tires are inflated properly, and reconnect
batteries.
2. Check all vehicle fluid levels and fill as required.
3. Start and run the vehicle at fast idle, until it reaches operating
temperature. To remove surface charge from the battery,
built up from previous start-ups and short idle periods,
operate the heater and / or air conditioner, headlights, and
other accessories for several minutes.
3