Game Composites GB1 GameBird, Руководство по обслуживанию

Страница: 266 / 269

Maintenance Manual GB1 GameBird
Page date: April 24, 2020
85-2
Description
The smoke system consists of two glass fiber tanks in each wing with collapsible silicone bladders inside
(36 liters /7.4-gal total capacity), an electrical pump is located in a compartment under the right front leg
support. Oil lines from each tank route into a T-fitting under the front seat, from there one line to the pump,
from there via a bulkhead fitting through the firewall into the exhaust collectors.
To fill the system, a T-fitting and a check valve are installed between the pump and the firewall bulkhead
fitting. An oil line routes from the T-fitting to a pneumatic connector, installed in the bottom of the fuselage,
accessible from underneath the plane, just aft of the right landing gear leg.
The Circuit Breaker Switch marked “SMOKE REFILL” reverses the polarity of the pump to fill or use the system.
The rocker switch on the throttle activates the pump.
The system can be deactivated by pulling the Button Circuit Breaker marked “SMOKE”.
Troubleshooting
Pump not working Check wiring and electrical connections
Uninstall and bench-test pump, replace if necessary
Check relay, replace if required
Check CB switch and switch on throttle, replace if required
System does not fill to full capacity Air trapped in system, run dry until pump slows down audibly,
indicating empty bladders
Smoke oil leaking out of wing drains Check bladders, replace if leaking
Smoke oil leaking during refill Clean / replace check valve
Smoke oil leaks Check hoses and connections, replace damaged components
Smoke oil leaking out of filler connector Check filler connector, replace if required
Smoke Oil Specification and Handling
•
Only paraffin-based oil is approved for use in the smoke system.
•
This oil is not considered an environmental hazard under the Globally Harmonized System of
Classification and Labelling of Chemicals (GHS), neither is it classified as dangerous under either
67/548/EEC (Dangerous Substances Directive) or 1999/45/EC (classification, packaging and labelling of
dangerous preparations).
•
In the event of eye contact, flush with water. If persistent irritation occurs, obtain medical attention.
•
Prolonged or repeated skin contact may cause skin irritation. Wash with water and soap.
•
Flash point 200°C (390°F)
•
Auto-ignition point >320°C (600°F)