Game Composites GB1 GameBird, Руководство по обслуживанию

Страница: 257 / 269

Maintenance Manual GB1 GameBird
Page date: April 24, 2020
77-2
Engine Monitor
For details of engine monitoring functions and components included in the Garmin G3x Touch System,
refer to section
40 .
Annunciator Lights Panel
Location: Rear instrument panel, above altimeter
Manufacturer: Game Composites
3201 SW I Street, Bentonville, AR 72712 USA
www.gamecomposites.com
The unit does not require regular maintenance.
If defective, the unit must be replaced.
To service the Annunciator Lights Panel:
1 Remove GPS antenna cover
2 Disconnect electrical connection
3 Unscrew faceplate, remove faceplate and unit in the back from airplane
4 Service or replace as required
5 To reinstall, reverse steps 1 – 3
6 To check, follow troubleshooting instructions below
Signature
7 Sign for correct installation
Troubleshooting Guide:
- To check functions of the LEDs, press test button on Panel.
- Check for loose connections, cable chafing, and power input to the unit
- Measure resistance in cables
Oil Temp high:
Red LED, triggered when the oil temperature reaches the upper limit, 245°F.
A separate oil temperature sensor (JEGS 41326), mounted in the branch port of a T-fitting on the upstream
port of the oil cooler, is used to provide the signal. To check for correct function:
- Dip the uninstalled sensor in oil, and heat up the oil
- If the light does not illuminate at 245°F, replace the sensor
Oil Press low:
Yellow LED, triggered when the oil pressure reaches the upper end of the lower caution range, 55psi or below.
The installed oil pressure sensor is used to provide the signal. To check for correct function:
- Manually spin propeller (with spark plugs removed) until oil pressure on MFD1 shows 55psi.
- Oil press caution light should extinguish
- If not, the unit may be faulty; contact Game Composites
Acrotank low:
Yellow LED, triggered when the fuel quantity in the Acrotank reaches 7 Gallons (legal VFR reserve) or less.
The installed capacitive fuel sender is used to provide the signal. To check for correct function:
- Drain Acrotank fuel.
- Caution light should illuminate at or below 7 gal remaining
- If not, the unit may be faulty; contact Game Composites