145
5-7-2. Inspection
01. measure the 10-link length -- out of specification for replacement Fig. 5-120
* 10-Link length limit: 150-1mm (5.91 in)
02. by using finger to check the chain tense, the 10-link is a distance between (1) and (11). Every time to
check 2 or 3 “10-link” Fig. 5-121
03. clean drive chain by placing it in kerosene and brush off dire. Next, dry the chain. Finally, lubricate the
chain. Fig. 5-122
* use: lubricate (SAE 30-50 motor oil) drive chain
04. inspect drive chain stiffness for any stiff -- replace Fig. 5-123
05. inspect the drive sprocket, if more than 1/4 teeth (1) wear - replace. Fig. 5-124
06. inspect the drive sprocket, if bent teeth -- replace
07. inspect the chain guide Fig. 5-116
5-7-3. Driven sprocket replacement steps Fig. 5-125, 5-125A
01. straighten the lock washer (1) tabs and remove the driven sprocket (2).
02. install a new driven sprocket and lock washers.
* torque: 2.4 kg-m
03. bend the lock washer tabs along the nut flats.
5-7-4- Installation
- reverse the “5-7-1” procedure and follows points as; Fig. 5-121
01. lubricate (Molybdenum disulfide grease) inner surface collar
02. tighten chain guide roller bolts
* torque: 0.9 kg-m
03. install drive chain. Be sure to put the master link clip (1) on the rounded end facing the direction of travel
Fig. 5-l26
04. tighten under guard bolts and rear wheel nuts
* torque (under guard) :
2.3 kg-m
* (rear wheel nuts):
4.5 kg-m
05. tighten drive sprocket holder screw and change pedal bolts.
* torque (crankcase cover):
1.0 kg-m
* (change pedal):
1.4 kg-m
06- adjust drive chain slack -- refer to part 3-15
* drive chain slack: 30-40mm (1.l8-1.57in)
07. tighten rear axle hub upper nut
* torque: 5.0 kg-m Fig. 5-117
08. tighten rear axle hub lower nut
* torque: 5.0 kg-m
Содержание ATV DXR 200
