84
3 MONTHS OR 5,000 MILES
•
Inspect fire extinguisher to see if fully charged.
•
Check first aid kits to see if fully equipped.
•
Oil all hinges and window latches for ease of operation.
•
Lubricate all window channels with silicone or graphite.
•
There is one drain hole in each floor section under windows. Be sure hole is clear of debris so any
water may escape.
•
Clean all rubber door seals and lubricate with rubber lubricant.
•
All rear and side emergency door latch slide bars to be lubricated with light grease to reduce friction.
•
Tighten all tie down bolts to 47-55 foot pounds torque at 1,000 miles, 2,000 miles, and quarterly there-
after.
•
Change main heater air filter (depending on operating conditions).
•
Grease emergency door hinges.
•
Check seat cushion clamps.
•
Inspect mounting bolts on body tie down.
•
Inspect mounting fasteners and upholstery on seats.
•
Lubricate bridge plate hinge and pivot on Collins wheelchair lift.
•
Clean and lubricate fold cam slot, platform cam slots and handrail V-block on Collins wheelchair lift.
•
Check fluid level in Collins wheelchair lift.
•
Lubricate hinge and latch mechanisms on access doors.
•
Check internal fasteners on electric stop arms.
•
Lubricate entrance door vandal lock.
•
Inspect heater valves to verify proper function.
•
Change engine oil and oil filter.
•
Inspect fuel cap, tank and fuel lines.
•
Inspect engine fuel tank vents.
•
Inspect engine air filter, replace if required.
•
Inspect driveshaft.
•
Lubricate universal joint and slip joint.
•
Lubricate clutch release bearing.
•
Inspect accelerator system cable.
•
Lubricate emergency brake linkage.
•
Lubricate brake calipers.
•
Clean and lubricate fuel stop solenoid.
•
Lubricate brake camshaft, king pins, tie rod ends and slack adjusters.
3 MONTHS OR 24,000 MILES
•
Inspect Bendix air dryer.
•
Check for loose or disconnected electrical connections and damaged wiring.
•
Check the vehicle brake warning system.
•
Check the brake fluid level of the master cylinder reservoir.
•
Check the hydro-max exterior and all connecting lines for fluid leakage.
•
Check brake linkage and brake calipers.
6 MONTHS OR 6,000 MILES
•
Check lubricant level in rear axle.
•
Inspect rear axle vent.
•
Clean and/or replace air compressor filters.
•
Check power steering fluid level.
•
Lubricate steering drag rod.
Содержание TC/2000
Страница 1: ...Owner s Manual TC 2000 ...
Страница 3: ...2 ...
Страница 106: ...105 NOTES ...
Страница 111: ...Part Number 1919331 Blue Bird Corporation P O Box 937 Fort Valley GA 31030 ...
