Page 63
MAINTENANCE
3
Using needle-nose pliers, carefully unplug the battery clip from the system by lifting the tab and pulling free.
4
Replace with a new Zimmer battery and re-install the battery compartment cover.
The
A.T.S.
4000TS System will immediately evaluate the new battery and begin charging.
CAUTION:
The
A.T.S.
4000TS System is designed to use Zimmer batteries only. Do not use any battery other
than the Zimmer battery. The system will not allow unauthorized batteries. Do not attempt to open, modify or
repair the battery. Replace the battery with a new Zimmer battery when the battery health is depleted.
CAUTION:
The
A.T.S.
4000TS System should be plugged in at least 10 hours before putting back into use to
ensure a full battery charge in case of emergency power loss
.
BATTERY-HANDLING RECOMMENDATIONS
•
Do not dismantle, open or shred the battery.
•
Do not expose the battery to heat or fi re. Avoid storage in direct sunlight.
•
Do not short-circuit the battery. Do not store cells or batteries haphazardly in a box or drawer where they may short-
circuit each other or be short-circuited by other metal objects.
•
Do not remove a battery from its original packaging until required for use.
•
Do not subject a battery to mechanical shock.
•
In the event of a cell leaking, do not allow the liquid to come in contact with the skin or eyes. If contact has been
made, wash the affected area with copious amounts of water and seek medical advice.
•
Do not use any charger other than that specifi cally provided for use with the equipment.
•
Observe the plus (+) and minus (–) marks on the battery and ensure correct use.
•
Do not use any battery which is not designed for use with the equipment.
•
Keep cells and batteries out of the reach of children.
•
Seek medical advice immediately if a cell or a battery has been swallowed.
•
Always purchase the correct battery for the equipment.
•
Keep batteries clean and dry.
CAUTION:
After extended periods of storage, it may be necessary to charge and discharge the battery several
times to obtain maximum performance.
•
Secondary batteries need to be charged before use. Refer to the
A.T.S.
4000TS Operator/Service Manual for
proper charging instructions.
•
Secondary batteries give their best performance when they are operated at normal room temperature
(20 °C ± 5 °C).
•
Retain the original product literature for future reference.
•
Use only the battery in the application for which it was intended.
•
Dispose of properly.
Notice: Battery Pack Disposal:
The battery is of a Lithium-Ion type. When the battery reaches the end of
its useful life, the battery should be disposed of by a qualifi ed recycler or hazardous materials handler. Do
not mix this battery with the solid waste stream. Contact your local recycler or hazardous material handler
for recycling or disposal information.