Volvo EC15E, Operator'S Manual

Page: 82 / 238

Long-term parking
NOTICE
If the machine is not going to be used every day, all
cylinders should be protected against corrosion.
1 Carry out the measures as described on
previous page. Remember that the ground on
which the machine is to stand may shift
depending on the weather. Therefore take
suitable action.
2 The temperature must not fall below -40 °C (-40
°F) or 70 °C (158 °F).
3 Check that the batteries are fully charged.
4 Disconnect the battery by removing the Quick
connector. Open the left hood with the ignition
key.
5 Wash the machine and touch up any damaged
paint finish to avoid rusting.
6 Rust-proof exposed components, lubricate the
machine thoroughly and grease all unpainted
surfaces like cylinder rods etc.
7 Fill the fuel tank and the hydraulic oil tank to the
max. marks.
8 Cover the exhaust pipe (for outdoors parking).
9 Drain water from any compressed-air reservoirs.
10 Make sure the freezing point of the coolant is
sufficiently low (in cold weather).
11 When storing machines in extreme cold
temperatures, remove batteries and store them
at room temperature. Make sure to place the
batteries over a wooden/plastic/rubber surface.
Check after long-term parking
All oil and fluid levels
Tension of all belts
V1129844
Long-term parking position
V1196713
Battery Quick connector under left hood
80
Operating instructions
Parking