– Insert hand-cartridge gun with -VAS 6621- at rear end of guide
rail -1- and turn it by 90° -2-.
– Apply lubricant - G 060 751 A2- for guide rails in direction of
-arrow 3- towards front of guide rail, applying uniform pressure
while operating hand-cartridge gun .
– Turn hand-cartridge gun with -VAS 6621- by 90° -4- and re‐
move it -5-.
– After lubricating, open and close panoramic sliding roof once,
then remove excess grease.
– Repeat the process on the other side of the vehicle.
Caution
Faults found must always be rectified (repair measure).
4.39.2
Wind deflector: clean.
– Check wind deflector -1- for soiling. Thoroughly check lower
part of wind deflector for soiling -arrows-.
– Remove dirt deposits with e.g. wet and dry vacuum cleaner.
– To remove insects and particles from the net and wind deflec‐
tor frame, use a sponge and a soapy solution.
Mixing ratio for soapy solution: 3 drops of washing-up liquid to 1
litre of water
Caution
Do not use a commercially available insect remover or other
solvents, because these products have not been tested and
approved.
– Then remove insects and particles using a vacuum cleaner
with a suitable nozzle.
Caution
The net on the wind deflector could be damaged if a wrong
nozzle is used.
– When doing this, ensure that no dirt drops into vehicle interior.
4.40
Road test: performing (driving behav‐
iour, noises, air conditioner etc.)
Which of the following can be checked depends on vehicle equip‐
ment and local conditions (urban/country).
Check the following during a road test:
♦ Engine: output, misfiring, idling speed, acceleration
♦ Clutch: pulling away, pedal pressure, odours
♦ Gear selection: ease of operation, stick position
Passat 2011 ➤ , Passat Variant 2011 ➤
Maintenance - Edition 01.2019
4. Descriptions of work:
119
