E-504
Achtung:
Während
der
Einstellung
darauf
achten,
dass
die
Anschlagsstangen nicht zu weit herausgedreht werden, da
sonst die Gefahr besteht, dass der Kolben aus dem
zylindrischen Bereich der Nabe springt und die Nabe dadurch
mit
Öl
kontaminiert
wird,
was
eine
komplette
Propellerzerlegung in einem authorisierten Servicebetrieb
erforderlich machen wuerde.
Wichtig -
bei Propellern mit Doppel-Kolben-System
Die 3 (2 oder 4) Anschlagstangen müssen zueinander
immer gleich eingestellt werden, ansonsten muß mit
einer Beschädigung der Verstellmechanik gerechnet
werden.
Fällt die Drehzahl sofort nach der geringsten Betätigung
ab, begrenzt der Regler die Standdrehzahl.
Abhilfe:
Reglerdrehzahl durch Herausdrehen der Anschlag-
schraube am Reglerhebel erhöhen. Eine Umdrehung
erhöht die Drehzahl um ca. 25 rpm
Wichtig
Der Bedienzug muß genügend Weg freigeben, daß der
Reglerhebel auch die Anschlagschraube berührt.
Anschlagschraube sichern.
Seite 33-1
17.02.2017
Attention:
During adjusting take care that the stop rods are not turned
out too much, otherwise it is possible the the piston jumps
out of the pitch change cylinder and the hub is full of oil,
which requires a complete propeller disasembly at a certified
propeller repair shop.
Important -
Propellers with Dual-Piston-System
The 3 (2 or 4) pitch stop rods must always have the
same setting towards each other. Otherwise the pitch
change mechanism will be damaged.
If the rpm drops immediately after a small movement
of the lever, the governor will limit the static rotational
speed.
Remedy:
Increase governor rpm unscrewing the stop screw.
One turn on the screw will change rpm by approx. 25
rpm
Important:
The control must be long enough to have the
necessary way in order to contact the stop. Secure
screw with safety wire.
Page 33-1
2017-02-17
Summary of Contents for MTV-12 Series
