Malmet Bedpan / Urinal Bottle Washer Disinfector (ES-D)
Detergent Model with Hands Free Operation
Operation, Maintenance and Installation Manual
Issue 5
Page
4
June 23
Intended Use
The Malmet Bedpan / Urinal Bottle Washer Disinfector is intended to be used by health service organisation personnel for
the cleaning and disinfection of medical devices during an automatic cycle of the types intended to be re-used as listed in
the design parameters section of this manual.
1.0 Design Parameters
The Malmet Bedpan / Urinal Bottle Washer Disinfector has been designed within the following parameters:
a)
To empty, clean and disinfect devices of the type listed below intended to be re-used and that have been soiled by human
excreta. *
b)
A single bedpan with lid and two urinal bottles can be emptied, cleaned and disinfected during each automatic cycle.
The utensils that can be cleaned in the device are: -
i)
Standard size bed pans
ii)
Standard commode bowl
iii)
Standard male and female urinal bottles
iv)
Most plastic urinal bottles including male non-spill and female urinal bottle
v)
Small slipper pan
vi)
Large slipper pan
c)
The cradle is designed to ensure that utensils are not dislodged during the cleaning cycle; the contents are emptied during
door closure.
d)
The chamber and door are self-cleaning and do not permit water or soil to remain after a properly completed cycle. Steam
disinfection ensures all internal surfaces are totally clean and safe.
e)
The flush and clean stage:
i)
Removes the soil
ii)
Clears the trap
f)
A complete cycle is completed in approximately four (4) minutes for the 20 Amp Bedpan /Urinal Bottle Washer Disinfector
and six (6) minutes and thirty (30) seconds for the 10 Amp Bedpan / Urinal Bottle Washer Disinfector
Note:
Dependant on ambient air temperature.
Note:
The first cycle will take longer as the device has to reach the operating water temperature
of 90˚C.
g)
Malmet Door Obstruction Feature
This is factory set to 12Nm ±10%; causing the door to re-open when an obstruction is detected. This is designed to protect the
integrity of the device and the articles within.
*
Non-flushable items such as Feminine Hygiene products, Incontenance or Absorbent pads & diapers, Condoms, Dental Floss,
Paper Towel, Cigarette butts, medications or chemicals cannot be disposed of in Malmet Washer Disinfectors and should be
disposed as per facility &/or local waste management requirements.
