GILES GBF-35, Operation & Service Manual

Page: 55 / 104

49
Fryer Operation
GBF − 35 / GBF − 50 Fryers
7. When cooking oil temperature reaches the programmed setpoint, the alarm sounds and display reads “ALARM ‐
STIR OIL” . Press [ALARM] key ⑤ to silence ... vigorously stir oil with the provided stirring tool . The controller
begins a ten (10) second delay ... during this time, if oil temperature drops below setpoint when stirred,
PREHEAT mode continues until the setpoint is reached again. Either after the delay or when lost heat is
recovered, the alarm sounds again & display reads “ALARM ‐ SETPOINT REACHED” . Press the [ALARM] key ...
controller enters READY state. The lower display changes from the actual oil temperature
to the controller temperature setpoint.
Cooking oil should now be evenly heated and ready for cooking.
Continued on Next Page
4.02.1 Filling & Preparing Fryer for Cooking − continued
8. After fully heating, confirm the oil level ... it should now be at or near the [FULL]
mark. If not, add the needed amount of oil & stir again. If the HEAT light turns ON
after adding additional oil, stir until it turns OFF again before cooking .
4.02.2 Loading Product for Cooking
1. Place crumb/support screen(s)
① into vat(s) ... handles to the side. Screen rest on
brackets affixed to the vat sides.
2. The standard
GBF fryer is equipped with a basket hanging rack along the back of
the cabinet ... hang empty baskets ② there.
Optional Auto ‐ basket Lifts: If the basket lift option is installed on your fryer, place
the cooking baskets onto the basket carrier
③ arms.
When the basket lift option is installed & you wish to utilize the feature
when cooking, set the control panel LIFT switch ④ in the [LIFT]
position. There will be no switch if the option is not installed .
See Section 4.01.7.1 for details about manually operating basket lifts.
2
1
4
NOTE:
If you do not wish to use installed basket lifts, move both carrier arms to the [UP] position (see Section 4.01.7.1) &
set the LIFT switch to [OFF] ... use carriers as the basket hangers .
Oil level MUST be maintained between [FULL] & [ADD] levels while cooking. If level falls
below [ADD], the controller may issue a LOW OIL LEVEL error & alarm. As safeguard against
possible oil fire, power to the heating elements is shutdown until condition is corrected.
3