Arctic Cat 2013 Prowler XT, Service Manual

Page: 18 / 233

2-7
2
4. Using the Oil Filter Wrench and a ratchet handle (or a
socket or box-end wrench), remove the old oil filter.

NOTE: Clean up any excess oil after removing the filter.
5. Apply oil to a new filter O-ring and check to make
sure it is positioned correctly; then install the new oil
filter. Tighten securely.
6. Install the engine drain plug and tighten to 16 ft-lb.
Pour the specified amount of the recommended oil in
the filler hole. Install the oil level stick/filler plug.
7. Start the engine (while the vehicle is outside on level
ground) and allow it to idle for a few minutes.
8. Turn the engine off and wait approximately one minute.
9. Unscrew the oil level stick and wipe it with a clean cloth.
10. Install the oil level stick and thread into the engine case.

NOTE: The oil level stick should be threaded into
the case for checking the oil level.
11. Remove the oil level stick; the oil level must be
within the operating range but not exceeding the
upper mark.
GZ461A
12. Inspect the area around the drain plug and oil filter
for leaks.
Front Differential - Rear
Drive Lubricant
To check lubricant, use the following procedure.
1. Remove the fill plug; the lubricant level should be
one inch below the plug threads.
PR530A
2. If low, add SAE approved 80W-90 hypoid gear lube
as necessary.
To change the lubricant, use the following procedure.
1. Place the vehicle on level ground.
2. Remove each fill plug.
3. Drain the lubricant into a drain pan by removing in
turn the drain plug from each.
ATV0082A
PR530B
4. After all the lubricant has been drained, install the
drain plugs and tighten to 45 in.-lb.
5. Pour the appropriate amount of recommended lubri-
cant into the fill hole.
6. Install the fill plug.

NOTE: If the lubricant is contaminated with water,
inspect the drain plug, fill plug, and/or bladder.
CAUTION
Any oil used in place of the recommended oil could cause
serious engine damage. Do not use oils which contain
graphite or molybdenum additives. These oils can
adversely affect clutch operation. Also, not recommended
are racing, vegetable, non-detergent, and castor-based oils.
CAUTION
Do not over-fill the engine with oil. Always make sure
that the oil level is not above the upper mark.
Front Differential
Rear Drive