Volkswagen 1995 Volkswagen Golf III GL, Руководство по обслуживанию

Страница: 3 / 60

FUEL PRESSURE RELEASE
Remove fuel pump relay (located in fuse/relay panel). Crank engine for 5 seconds. Turn ignition switch off.
Reinstall fuel pump relay.
RADIATOR
Removal & Installation (Jetta)
1. Disconnect and remove battery. Drain engine coolant by disconnecting coolant hose from thermostat
housing. Disconnect radiator hoses. Disconnect fan harness connectors. Remove headlights. Remove
radiator mounting bolts.
2. On vehicles equipped with A/C, remove air cleaner. Remove A/C line retaining clamps. DO NOT
disconnect hoses. Separate condenser from radiator and move radiator forward.
3. On all vehicles, remove radiator. To install, reverse removal procedure. Fill cooling system. Adjust
headlights.
Removal & Installation (Beetle)
1. Remove center undercar tray. Drain coolant from radiator. Remove front inner fenders. Remove
fender bolts from inside of fender. See Fig. 2 . Remove lower fender bolts. Remove screws from rear
of fender. Remove 3 screws from under front of bumper cover. Remove 16 screws under hood
attaching fenders and bumper cover to vehicle. With a helper, remove front fenders and bumper cover
as an assembly.
2. Disconnect hood latch cable. Remove upper bumper bolt on each side and install Special Tools
(3411). See Fig. 3 . Remove upper panel bolts and remaining bumper bolts. Slide entire lock carrier
assembly out on special tools.
3. Disconnect radiator hoses. Disconnect radiator mounted switch harness connectors. Remove radiator
mounting bolts. See
Fig. 4
. On vehicles equipped with A/C, remove A/C line retaining clamps. DO
NOT disconnect hoses. Fasten condenser to lock carrier before removing radiator. On all vehicles,
remove radiator. To install, reverse removal procedure. Fill cooling system. Adjust headlights.
NOTE: For reassembly reference, label all electrical connectors,vacuum hoses and
fuel lines before removal. Place mating marks on other major assemblies
before removal.
NOTE: Obtain radio anti-theft code before disconnecting battery.
1995 Volkswagen Golf III GL
2.0L 4-CYL
1 января 2005 г . 1:18:59 Page 3 © 2004 Mitchell Repair Information Company, LLC.