Sovan's CTD10R-E, Руководство по эксплуатации

Страница: 42 / 45

37
report it to the superior in concern. It is forbidden to repair or adjust the truck by the truck by the
driver without permission.
The truck which fuel oil system is leaking could not be uses without repair.
14.2.4.2 Refuel
Before refuel, it is necessary to close the engine, brake the truck and the driver should leave the
truck.
The open flame and smoking is forbidden during refueling.
14.2.4.2.1 Liquid fuel (for example gasoline and diesel fuel)
The truck using liquid fuel should add fuel in the appointed places.
Before take away the refueling equipment, cover the filler cap and clear up the excessive fuel, the
engine could not start up.
14.2.4.2.2 Liquefied petroleum gas fuel (liquefied petroleum gas)
Only the personnel trained and appointed can refuel or change the liquefied petroleum gas
container.
The person charging for refuel liquefied petroleum gas should wear protective suit (that is to say
long sleeve unit and glove).
The pouring of the fixed type liquefied petroleum gas container and the pouring and change of the
liquefied petroleum gas container should be carried on the appointed place.
When transporting or conveying the liquefied petroleum gas container, it is necessary to be careful,
the container should not fall down, nor be thrown, rolling or draw. If it is necessary to transport
several containers one time, a proper transporting device should be adopted.
The liquefied petroleum gas container should not be filled in excessive.
Before filling the fuel, power off the engine, brake the truck, and the driver leave away the truck.
It is necessary to using soap liquid to check the leak dictation.
The truck driven by liquefied petroleum gas could not park near the heat source, open flame or the
similar ignition, and not near to the open air pit, the entrance of the under crossing, the elevator
well or other similar place, and could not change the removable container in the upper place.
Before fill fuel into all liquefied petroleum gas container and before the reuse of the removable
liquefied petroleum gas container, it is necessary to inspect if there is defect or damage as follows:
A
）
the dent, scoring and groove of the pressure container;
B
）
the damage of any kinds of valve and fluid level gage;
C
）
the scraping in the safety valve;
D
）
the damage or the lose of the safety bonnet;
E
）
the leak in the connection of valve or screw-threaded joint;
F
）
The deterioration, damage or lose of the flexibility seal in the connection of prime or air feed.
If finding the above defect and/or damage, the container should not be used until repaired.
The truck which is driven by liquefied petroleum gas is over night or stay indoor for a long time and
the liquefied petroleum gas container stayed on the truck, it is necessary to close all of the feed
valves on the container.
14.2.4.3 The charging and changing of the battery
The charging and changing of all the battery should be carried out by the personnel who has been
trained and appointed
staves and proceed as the description of the user’s manual of the battery or
truck factory. As usual the driver can be appointed.
Before charging or changing battery, the truck should be located correctly and brake.
When charging, the exhaust cap should be in the correct position to prevent the electrolyte spilling