![background image](http://html1.mh-extra.com/html/lancer/centurion-ii-85-0056/centurion-ii-85-0056_installation-and-service-manual_672757025.webp)
Figure 2
E. Remove both paddles and splash plate from
unit.
F. Remove sensors from mounting bracket and
install in pump support. Allow approximately
3/8 inch (9.525 mm) for sensor to extend from
pump support (see Figure 3).
G. Replace splash plate.
H. Assemble the pushbutton assembly (see
Figure 4) to front cover. Be sure to place
dispense label (Item No. 4) on unit before
installing pushbutton components.
You must
tighten jam nut (Item No. 7) on rear of front
cover to prevent damage to dispense label.
I.
Reinstall front cover.
J. Push each button to test for dispense. If unit
does not dispense, sensor may need to be
extended more from unit (see Figure 3).
Figure 3
21
9. INSTALLATION OF PUSHBUTTON KITS FOR CENTURION II
(Pushbutton Kit Part No. 82-0676)
To assure proper installation in converting a Centurion II from paddle dispense to pushbutton dispense,
complete the following instructions carefully. A Centurion unit has a Serve/Flush switch, so
note additional
instructions in Section 10
. It will be necessary to drill four (4) holes to convert unit. Needed will be an
1/8" and a 9/16" bit. Included in this kit is a four (4) part template. The template assures proper location
of holes.
A. Place each part of template in proper location as shown in Figure 2, each template section is
marked for correct location.
This must be done precisely to ensure proper alignment.
B. Holes to be drilled as shown by the four (4) dotted circles.
It will be necessary to remove front
cover to drill holes.
C. On the front cover, first drill a pilot hole using an 1/8" bit (on the front side); then from the back,
using a 9/16" bit complete the hole.
D. After drilling all holes, remove template and remove all plastic burrs.
Содержание CENTURION II 85-0056
