Airxcel Aqua-Hot 200 Series, Руководство по обслуживанию

Страница: 4 / 105

Introduction
©Aqua-Hot®
250-D03 Diesel Series Service Manual REV 220302
p. 4
WHAT TO DO IF YOU SMELL GAS
• Evacuate all persons from the vehicle.
• Shut off the gas supply as the gas container or source.
• Do not touch any electrical switch or use any phone or radio
in the vehicle.
• Do not start the engine or electric generator (if equipped).
•
Contact the nearest gas supplier or qualified service
technician for repairs.
• If you cannot contact the nearest gas supplier or qualified
service technician , contact the nearest fire department.
• Do not turn on the gas supply until the gas leak or leaks (if
relevant) have been repaired.
• Installation and service must be performed by a qualified
installer, service agency, or gas supplier.
The Aqua-Hot’s exhaust is HOT!
• Do NOT park in areas where dry conditions exist (IE grassy,
dry fields).
• Do NOT operate the burner inside an enclosed building.
• The heater must be switched OFF when refueling.
Read all instructions before servicing the Aqua-Hot unit. Aqua-
Hot Heating Systems is not liable for damage resulting from
failing to follow instructions contained in this, and any other
Aqua-Hot documentation relevant to this unit.
• Read this manual before servicing or using the Aqua-Hot
System to reduce the risk of injury to persons or damage to
the equipment.
• The product identity label contains specifications of the
unit, to what standards it has been tested, and important
safety notices.
• The Aqua-Hot must be installed in a compartment that is
closed off from living quarters and accessible only from the
exterior of the vehicle.
•
Propylene glycol
based antifreeze “Generally Recognized
As Safe” (GRAS) by the FDA must be utilized for the
antifreeze and water heating solution.
• An interlock switch prevents the Aqua-Hot heater from
operating when the cover is not installed in the correct
position.
• Disconnect electric wiring to the Aqua-Hot System before
welding or plasma cutting the RV to avoid damage to
equipment.
• The Aqua-Hot tank and heating loop operate at 0.0 PSI
(zero pressure system). Air pressure to the tank must not
exceed 20 PSI. Exceeding this rating will cause internal
damage to the Aqua-Hot.
• Use caution when working on or near any diesel fuel system.
•
Do not store or use gasoline or other flammable vapors or
liquids in the vicinity of this or any other appliance.
• The Aqua-Hot’s exhaust is HOT and must be kept away from
heat sensitive material.
• DO NOT connect the 12-volt DC power to the Aqua-Hot if the
vehicle requires welding.
• At maximum operating temperature, the coolant will be
very hot and scalding. Hot vapor or coolant may cause in
serious burns or injury. Be aware of hot surfaces.
• Do NOT activate the burner until the antifreeze and water
heating solution has been added to the boiler tank to avoid
serious damage to the heater.
• Installation and repairs may only be carried out by an
authorized, factory-trained A qua-Hot technician. The
heating system must be installed in accordance with local
codes, or in accordance with the Standard for Recreational
Vehicles, (RVIA) ANSI A 119.2/NFPA 501C, NFPA 1192.
If the information in this manual is not followed exactly,
a fire or explosion may result, causing property damage,
personal injury or death.
NOTE:
Should any additional assistance be needed, please
contact the Technical Support Department at 574-AIR-XCEL
(574-247-9235).
NOTE: Service parts and accessories are available through
Aqua-Hot Factory Authorized Service Centers or at www.
aquahot.com.