Zetor FORTERRA HSX Series, Operator'S Manual, Page: 165 / 222

Battery disconnector
P18N100
The battery disconnector is located on the left side of the tractor behind the driver's stairs.
A - Battery connected
B - Battery disconnected
C - Disconnector plate is located on the cover of the accumulator battery
During tractor shutdown disconnect the battery using the battery disconnector. When the
tractor is shutdown for longer time it is necessary to charge the battery at least once in three months
due to battery auto discharge.
Attention! When the engine is switched off, the control unit of the engine and of the exhaust
system remains active for about 2 minutes because of storage of the engine operation data and
drawing of urea back into the tank. During this time the supply of current from the accumulator must
not be interrupted. Do not disconnect the accumulator before this time expires.
Accumulator battery maintenance
F298
Keep the accumulator battery clean and properly fixed to the vehicle. However, the fixing device must not
deform the battery case. In the case of polypropylene batteries the electrolyte level must not be below the
minimum mark indicated on the case.
Only add distilled water to the battery!
1. When working with the battery first read the attached manual.
2. During work with the battery protect your eyes with goggles or a safety shield!
3. The electrolyte is a caustic substance; therefore, handle it with proper care.If your skin or clothes
get stained by electrolyte, wash the skin or clothes with water and neutralize them with soap.
4. During charging hydrogen is released from the electrolyte on the electrodes. Hydrogen mixed with
the air forms an explosive mixture. Therefore, it is prohibited to handle open fire near the battery
during charging.
5. An explosion may also be caused by a spark created on the disconnection or release of a terminal
when the charging circuit is on.
6. Keep the battery out of reach of children!
7. A discarded battery is dangerous waste for the environment - when buying a new battery hand the
old one over to the dealer, who will dispose of it free of charge.
ELECTRIC INSTALLATION
164