PERIODIC MAINTENANCE
3-14
1. Remove:
• Brake fluid reservoir cover “1”
TIP
After removing the brake fluid reservoir cover, in-
stall the brake fluid reservoir temporarily.
2. Bleed:
• ABS
▼▼▼
▼
▼ ▼▼▼
▼
▼ ▼▼▼
▼
▼ ▼▼▼
▼
▼ ▼▼▼
▼
▼ ▼▼▼
▼
▼▼▼
a. Fill the brake master cylinder reservoir or
brake fluid reservoir to the proper level with
the specified brake fluid.
b. Install the diaphragm (brake master cylinder
reservoir or brake fluid reservoir).
c. Connect a clear plastic hose “1” tightly to the
bleed screw “2”.
d. Place the other end of the hose into a con-
tainer.
e. Slowly apply the brake several times.
f. Fully squeeze the brake lever or fully depress
the brake pedal and hold it in position.
g. Loosen the bleed screw.
TIP
Loosening the bleed screw will release the pres-
sure and cause the brake lever to contact the
throttle grip or the brake pedal to fully extend.
h. Tighten the bleed screw and then release the
brake lever or brake pedal.
i. Repeat steps (e) to (h) until all of the air bub-
bles have disappeared from the brake fluid in
the plastic hose.
j. Check the operation of the hydraulic unit.
Refer to “HYDRAULIC UNIT OPERATION
TESTS” on page 4-67.
NOTICE
ECA1XC1004
Make sure that the main switch is set to
“OFF” before checking the operation of the
hydraulic unit.
k. After operating the ABS, repeat steps (e) to
(i), and then fill the brake master cylinder res-
ervoir or brake fluid reservoir to the proper
level with the specified brake fluid.
l. Tighten the bleed screw to specification.
m. Fill the brake master cylinder reservoir or
brake fluid reservoir to the proper level with
the specified brake fluid.
Refer to “CHECKING THE BRAKE FLUID
LEVEL” on page 3-11.
WARNING
EWA1XC1008
After bleeding the hydraulic brake system,
check the brake operation.
▲▲▲
▲
▲ ▲▲▲
▲
▲ ▲▲▲
▲
▲ ▲▲▲
▲
▲ ▲▲▲
▲
▲ ▲▲▲
▲
▲▲▲
3. Install:
• Brake fluid reservoir cover
EAS21280
CHECKING THE FRONT BRAKE HOSE
1. Check:
• Brake hose “1”
Cracks/damage/wear
→
Replace.
A. Front brake caliper
B. Rear brake caliper
1
1
2
A
1
2
B
T
R
.
.
Brake caliper bleed screw
6 Nm (0.6 m·kgf, 4.3 ft·lbf)
T
R
.
.
Brake fluid reservoir cover bolt
2.8 Nm (0.28 m·kgf, 2.0 ft·lbf)
LOCTITE®
Summary of Contents for XVS950CU 2014
