Maintenance Manual STEMME S10-VT
Date of Issue: Dec. 19, 1997
Page: 5-2
Amendment No.: 23
Date: Jan. 29, 2015
A4011121_B23.doc
Doc. No. A40-11-121
5.1 Overhaul and Replacement Schedule
This section contains times recommended by the manufacturer for replacement or overhaul of components
not subject to the Maximum Allowable Operating Times of Chapter 4. For life
–
limited parts with separate TC
or TSO, refer to the Airworthiness Limitations section of the manufacturer
’s
documentation (applicable
Maintenance Manual, Service Bulletin etc.) for permissible service
–
life limits prescribed by the respective
manufacturer.
The following components should be overhauled or replaced at their respective specified TBO or
Replacement Interval (TBR) or sooner, if their condition so indicates, and reasonable care requires it.
STEMME strongly recommends adherence to the Chapter 5 overhaul and replacement schedule, including
the overhaul and replacement times applicable to the components listed below. Overhaul and replacement of
these items is to be done on condition but as STEMME recommendation not later than stated in the following
table.
Log Book entries
Inspections, maintenance, and preventive maintenance including correct observation of the overhaul and
replacement times and the date of removal, installation or overhaul of each component should be logged in
strict compliance with applicable national requirements.
NOTE:
Aircraft storage or operation under less favorable or sub-normal conditions often requires
more frequent inspection, overhaul, or replacement of components than at the intervals
recommended below.
More frequent inspection includes careful inspection before each flight. The
owner and operator are ultimately responsible for keeping the aircraft in airworthy condition based on
the defined requirements of the TC holder with the informed advice of an authorized maintenance
person.
Recommended Operating Times Between Overhaul and Replacement:
No.
Part/Assembly/
Equipment
Manufacturer,
Type
IPC
Chapter
Recommended op. time by
Notes
Overhaul Replacement
1 Engine
STEMME,
ROTAX 914F2/S1
71-01
See Note (1)
-
(1)(3)
(4)
2 Rubber parts of the engine
ROTAX,
Various Rubber
71-01
See Note (2)
-
(2)
3 Fuel hoses
Various,
STEMME approved
28-10
-
5 years
(5)
4 Lubrication hoses
Various,
STEMME approved
79-20
-
5 years
(5)
5 Coolant hoses
Various,
STEMME approved
75-20
-
5 years
(5)
6 Brake hoses
Various,
Non-Teflon Type
32-40
-
10 years
(6)
7 Neoprene hoses
Various,
STEMME approved
75-20
-
5 years
(5)
8 Silicone hoses
Various,
STEMME approved
75-20
-
5 years
(5)
9
Fuel check valves
- plastic
–
bodied only.
Various,
Plastic Type
28-20
-
10 years
(5)(7)
10
Elastomer parts of the
landing gear suspension
Various,
Elastomer
32-00
-
10 years
(5)
11 Seat belts
Various,
Four
–
Point
24-10
See Note (8)
-
(8)(11)
