Ski-Doo Skandic Series 2016, Operator'S Manual

Page: 91 / 163

MAINTENANCE PROCEDURES
mmo2010-009-007_b
TIGHTENING SEQUENCE
STOPPER SCREW TIGHTENING
TORQUE
10 N•m ± 2 N•m (89 lbf• in ± 18 lbf• in )
NOTICE
Serious pulley damage
can occur if the engine stopper and
its screws are not properly installed.
Brake Fluid
Recommended Fluid
Use only DOT 4 brake fluid from a
sealed container. An opened container
may be contaminated or may have ab-
sorbed moisture from the air.
WARNING
Use only DOT 4 brake fluid from a
sealed container. To avoid serious
damage to the braking system, do
not use fluids other than the rec-
ommended one, nor mix different
fluids for topping up.
NOTICE
Brake fluid can damage
painted and plastic parts. Handle
with care. Rinse thoroughly in case
of spillage.
Brake Fluid Level Verification
Place vehicle on a level surface.
Check brake fluid in reservoir for proper
level. Add recommended brake fluid
as required.
mmo2008-008-018_a
1. Minimum
2. Maximum
3. Operating range
CAUTION Avoid getting brake
fluid on skin or eyes - it may cause
severe burns. In case of contact
skin, wash thoroughly. In case of
contact with the eyes, immediately
rinse with plenty of water for at least
10 minutes and then consult a doc-
tor immediately.
Gearbox Oil
Recommended Gearbox Oil
RECOMMENDED GEARBOX OIL
XPS SYNTHETIC GEAR OIL (75W
140) (P/N 293 600 140)
NOTICE
The gearbox of this snow-
mobile has been developed and val-
idated using the XPS™ Synthetic
gear oil. BRP strongly recommends
the use of its XPS Synthetic gear oil
at all times. Damages caused by oil
which is not suitable for the gearbox
will not be covered by the BRP lim-
ited warranty.
Access to Gearbox
Remove upper and lower side panels,
refer to
CONTROLS, INSTRUMENTS
AND EQUIPMENT
.
_______________
89